2006 Ford F-150 Power Train

The shift cable for the automatic transmission was routed next to the exhaust manifold on the engine. The shift cable gets hot and burns into from the heat off the exhaust manifold. I purchased the 2006 Ford F150 used. I had mechanic replace one shift cable with a new shift cable. The new shift cable burned into has I was backing in my driveway. I did research on the internet for trucks in that year range and it included other trucks 2007 and 2008 F150 having the same issue. You can find a ton of utube videos . ShowIng mechanics finding solutions to prevent the shift cables from burning into. I contacted Ford motor company about it. Ford wanted me to take the truck to a dealership and let them diagnosed the problem. The dealership wanted me to pay them a 150 dollars to look at it. I was not going to pay them for something that I already knew the answer too. So it is a manufacturing flaw with the way Ford put the shift cable on 2006 F150 and other F150's in that year range. I hope you research the issue and get back to me soon. Sincerely Yours [XXX] Ph [XXX] [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

MY 2006 FORD F 150 HAS 125,000 MILES. I WENT TO PUT MY TRUCK IN REVERSE TO BACK UP OUT OF MY DRIVEWAY AND IT MADE A NOISE. APPARENTLY REVERS BAND IN THE TRANSMISSION WENT. I NO LONGER CAN PUT MY VEHICLE IN REVERSE TO BACK UP. VERY FRUSTRATED BECAUSE THE VEHICLE IS VERY WELL MAINTAINED AND IT BROKE FOR NO REASON.

THE MECHANIC SAID I NEED TO REPLACE MY TRANSMISSION, IT IS AN AUTOMATIC 4.6L MOTOR AND DOES NOT GET 4RD OR 4TH GEAR. MY VEHICLE WAS IN MOTION AND WHEN IT REACHED 40MPH IT WOULD NOT GO I HAD TO SWITCH TO 2ND GEAR.

TRANSMISSION HAS A DELAY SHIFTING OR KIND OF GET STOCK THE TRANSMISSION WAS REPLACED AT 80000 MILES AND DOING IT AGAIN

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS UNABLE TO SHIFT THE GEAR INTO DRIVE OR REVERSE, ONLY NEUTRAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE CLUTCHES AND BANDS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 28,854. UPDATED 7/16/15*CN THE CONSUMER STATED THE TAIL SHAFT HOUSING HAD A HAIRLINE FRACTURE/CRACK WITH. THE REPAIRMAN BELIEVED THE PART WAS DEFECTIVE. THERE WAS NO WEAR ON THE INSIDE OF THE TRANSMISSION, BEARING OR SEALS. UPDATED 08/04/15*JB

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE STEERING WHEEL BECAME TIGHT AND LOOSENED UP AT RANDOM TIMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE DRIVESHAFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 25 MPH, THE TRANSMISSION CHANGED FROM TWO WHEEL DRIVE TO FOUR WHEEL DRIVE INDEPENDENTLY. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,000. UPDATED 3/4/15*CN THE CONSUMER STATED THE CAUSE OF THE FAILURE WAS A FAULTY SOLENOID. UPDATED 10/15/2015 *JS

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE MAKING A TURN AT AN UNKNOWN SPEED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE DEALER STATED THAT THE REAR DIFFERENTIAL FLUID NEEDED TO BE REFILLED. THE FLUID WAS REPLENISHED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE REAR DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 110,678.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT UPON TRAVELING OVER APPROXIMATELY 40 MPH ATTEMPTING TO ACCELERATE, THE VEHICLE HESITATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

MY TRUCK WAS NOT INVOLVED IN AN ACCIDENT. I HAVE 74,000 MILES ON MY TRUCK AND THE TRANSMISSION IS STARTING TO SLIP. WITH THIS LOW MILEAGE THIS SHOULD NOT BE HAPPENING. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE SHIFTED OUT OF GEAR WHILE AT A STOP AND THEN LUNGED FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE TRANSMISSION HAD DEVELOPED A PLANETARY NOISE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE FAILURE MILEAGE WAS 24,000. THE CURRENT MILEAGE WAS 35,800.

WENT TO BACK UP AND NO REVERSE. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ACTIVATED, THE ENGINE RPMS INCREASED AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE VEHICLE DRIFTED BACKWARD AND CRASHED INTO ANOTHER VEHICLE. THE CRASH CAUSED NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 96,000 AND THE CURRENT MILEAGE WAS 96,500.

TRANSMISSION JUMPS IN HIGH GEAR WHEN OVERDRIVE IS ACTIVE. *TR

TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE HAVING THE TIRES CHANGED THE MECHANIC NOTICED THAT THE REAR COVER ON THE DIFFERENTIAL WAS COVERED WITH RUST AND CAUSED A LEAK. THE VEHICLE WAS REPAIRED FOR THE REAR COVER AND OIL WAS ADDED FOR LUBRICATION. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 102,000. UPDATED 07/08/11 *BF UPDATED 09/16/11

WHILE DRIVING MY 2006 FORD F150, THE GEAR SHIFT CABLE MELTED DUE TO CONTACT WITH THE MANIFOLD. THIS CAUSE THE TRUCK TO STOP. I COULD NOT START THE TRUCK AGAIN. THIS HAPPENED WHEN I BACKED OUT OF MY DRIVEWAY. THE TRUCK WAS TAKEN TO THE FORD DEALER BY FLATBED. *TR

GLAZE ON REAR END CLUTCH CAUSING TRUCK TO DRIVE INCORRECTLY...CONTACTED COMPANY AND THEY HAD A POSSIBLE RESOLUTION THAT DIDN'T WORK....WORRIED THAT THE REAR END WILL LOCK UP WHEN DRIVING CAUSING A WRECK!! *TR

TL* THE CONTACT OWNS A 2006 FORD F-150 EQUIPPED WITH 4 WHEEL DRIVE. THE CONTACT STATED THAT THE REAR DIFFERIENTIAL WAS NOT FUNCTIONING CORRECTLY AND THE REAR WHEELS FELT AS IF THEY WERE SLIDING FROM THE REAR OF THE VEHICLE. ALSO, THE REAR OF THE VEHICLE SEEMED TO HAVE NO TRACTION. HE HAD THE REAR DIFFERENTIAL REPLACED. THE CONTACT'S MAJOR CONCERN WAS THAT ONE COULD LOSE CONTROL OF THE ENTIRE VEHICLE IF THE REAR FUNCTIONED IN THIS MANNER. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000. THE CURRENT MILEAGE WAS APPROXIMATELY 40,000.

IWE SOLENOID FAILS TO ENGAGE 4WD SYSTEM. 1ST FAILURE DURING ICE STORM. DEALER REPLACED IWE. 2ND FAILURE 6 MO'S LATER, DEALER REPLACED IWE ADDED "BARE BOND TAPE" TO COVER OVER SOLENOID. 3RD/4TH FAILURE HAS OCCURRED DURING RAINY CONDITIONS OR AFTER I WASHED THE TRUCK. THE 4WD WOULD NOT ENGAGE UNTIL I HAD DRIVEN THE VEHICLE OVER 5 MILES. VEHICLE BACK AT DEALER FOR SAME PROBLEM 3 TIMES IN LESS THAN 12 MONTH PERIOD. *TR

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE DRIVING 60 MPH HE HEARD CLANGING NOISES IN THE REAR END OF THE AXLE. HE THEN PULLED OVER TO INSPECT THE VEHICLE, BUT HE COULD NOT IDENTIFY THE CAUSE. AFTER SEVERAL DAYS WHILE DRIVING, THE FAILURE RESURFACED. UPON FURTHER INSPECTION HE NOTICED THAT THE CARRIER BEARING AND THE DRIVE SHAFT WERE LOOSE. THE MANUFACTURER WAS NOTIFIED AND HE WAS ADVISED THAT THE THREE YEAR WARRANTY EXPIRED , THEREFORE, HE WOULD HAVE TO PURCHASE A NEW DRIVE SHAFT FOR $750.00 PLUS LABOR. NO REPAIRS WERE MADE, AND THE VEHICLE WAS NOT DRIVABLE. THE FAILURE AND CURRENT MILEAGES WERE 29000. UPDATED 11/12/09 *CN UPDATED 11/16/09

THE INTEGRATED WHEEL END SOLENOID IS PRONE TO WATER FROM THE COWL DRAINING ONTO IT, THUS SHORTING OUT AND ALLOWING THE 4X4 VACUUM SYSTEM TO LOSE VACUUM. WHEN THIS HAPPENS, THE TRUCK'S FOUR WHEEL DRIVE SYSTEM ENGAGES UNEXPECTEDLY AND CAUSES DAMAGE TO THE WHEEL HUBS. ONCE THIS HAPPENS, THE DEALERSHIP COSTS ARE VERY EXPENSIVE, REQUIRING A NEW IWE SOLENOID, VACUUM SYSTEM, AND FRONT HUBS. *TR

LAST YEAR MY BRAKES FAILED ON MY FORD F-150 2006, FORTUNATELY I WAS CLOSE BY THE DEALERSHIP I PURCHASED THE VEHICLE FROM. LAST MONTH MY DAUGHTER WAS DRIVING MY TRUCK AND THE REAR WHEELS LOCKED UP ON THE SAME TRUCK, ALMOST CAUSING HER TO GO OVER A BRIDGE, THE RAIL STOPPED HER. I JUST WANT TO KNOW IF ANY OTHERS HAVE HAD THIS SAME EXPERIENCE. *TR

I DRIVE A 2006 FORD F150. IN JULY 2007 I STARTED HEARING A GRINDING NOISE COMING FROM MY FRONT WHEELS. I BROUGHT IT TO HOLMAN FORD IN TURNERSVILLE NEW JERSEY. THEY REPLACED AUTO 4WD VACUUM SOLENOID. NOW 15 MONTHS LATER THE NOISE IS BACK AND THEY SAID THEIR PARTS AND LABOR WARRANTY IS ONLY GOOD FOR 12 MONTHS. I KNOW OTHER PEOPLE WHO HAD THE SAME PROBLEM BUT THEY SAID THERE IS NO RECALL. IT IS OBVIOUS THERE IS A DEFECT. *TR

WITHIN THE LAST 2 MONTHS, 3 DIFFERENT TIMES JUST DRIVING DOWN THE ROAD WILL ALL OF A SUDDEN HEAR GRINDING NOISE. *TR