2003 Ford Focus SERVICE BRAKES, HYDRAULIC

LEAKING BRAKE LINE. THE LEAK WAS CAUSED BY THE FRONT LEFT PLASTIC INNER FENDER RUBBING AGAINST THE BRAKE LINE. I HAVE DIGITAL PICTURES AVAILABLE. *TR

MANUFACTURING DEFECT PLACES THE PLASTIC INNER FENDER AGAINST THE FRONT LEFT BRAKE LINE. THE PLASTIC INNER FENDER IS ALLOWED TO RUB A HOLE IN THE FRONT LEFT BRAKE LINE. THE FRONT LEFT BRAKE LINE LEAKED DUE TO WEAR CAUSED BY THE PLASTIC INNER FENDER. LOSS OF BRAKES DUE TO A HOLE IN THE FRONT LEFT BRAKE LINE. *TR

AFTER A TWO-WEEK VACATION, I WAS GOING TO DRIVE MY 2003 FORD FOCUS TO WORK. AS I WAS BACKING OUT OF THE GARAGE, I NOTICED THAT THE BRAKES WERE EXTREMELY SOFT. THE REPAIR SHOP THAT DIAGNOSED AND REPAIRED THE PROBLEM TOLD ME THAT I HAD A TOTAL FAILURE OF THE MASTER CYLINDER WHICH CONTROLS BOTH THE CLUTCH AND BRAKES. THEY ALSO SAID THAT THIS IS THE SECOND INCIDENT THAT THEY WERE AWARE OF. REPAIR INCLUDED A NEW MASTER CYLINDER AND REPLACEMENT BRAKE FLUID. I DO NOT KNOW IF IT WAS COINCIDENCE OR NOT, BUT THEY ALSO DISCOVERED THAT MY REAR WHEEL CYLINDERS HAD ALSO "EXPLODED." REPAIR REQUIRED CYLINDER AND DISC REPLACEMENT. OLD PARTS HAVE BEEN RETAINED. *TR

BRAKE LOCKUP UNDER ABS. WHEN THE VEHICLE IS ENGAGED IN A BRAKING EVENT SUFFICIENT TO ACTIVATE THE ABS SYSTEM, ALL FOUR BRAKES LOCKUP AND DO NOT RELEASE UNTIL THE VEHICLE HAS COME TO A COMPLETE STOP. THIS HAS HAPPENED UNDER WINTER CONDITIONS (SNOW/ICE), IN THE RAIN AND IN THE DRY. THE INCIDENT IN THE RAIN OCCURRED WHEN ATTEMPTING TO TAKE AN EXIT RAMP OFF OF AN INTERSTATE. THE CAR BRIEFLY HYDROPLANED ENOUGH FOR THE ABS TO ACTIVATE, AND THEN WENT OUT OF CONTROL WITH THE TIRES LOCKED UP. THE CAR SLID OFF OF THE EXIT RAMP AND INTO THE GRASS, WHERE IT FINALLY CAME TO REST. LUCKILY NO ONE WAS HURT. THE INCIDENTS IN THE DRY TOOK PLACE DURING AN AUTO-CROSS ON A CLOSED COURSE AND WERE SUFFICIENT TO SEVERELY FLAT-SPOT THE TIRES. THIS HAPPENS EVERY TIME ABS IS ENGAGED UNDER HARD BRAKING. OCCASIONALLY, IT IS POSSIBLE TO DOWN-SHIFT AND "DRIVE THROUGH" THE BRAKES WITHOUT COMING TO A COMPLETE STOP. THERE IS NO DASH LIGHT OR ANYTHING TO INDICATE A PROBLEM. THE REAR-WHEEL TONE RINGS HAVE BEEN REPLACED AND THE FRONT-WHEEL TONE RINGS HAVE BEEN CLEANED. ALL FOUR SENSORS HAVE BEEN CLEANED AND ELECTRICAL CONNECTIONS CHECKED FOR LOOSENESS. *TR

ROTORS AND BRAKE PADS WEAR DOWN FASTER THAN I CAN AFFORD TO FIX THEM. ROTORS ONLY LAST 1-2 MONTHS THEN BEFORE WARPING THEN I RIDE THEM OUT FOR ANOTHER MONTH (NO MONEY TO KEEP REPLACING) THIS HAS BEEN AN ONGOING PROBLEM FOR 2 YEARS. I HAVE RECEIPTS AND MECHANICS PROOF. ITS CRAZY. I HAVE ALSO VERIFIED SAME PROBLEM ON OTHER CAR COMPLAINT WEB SITES WITH PEOPLE AND FORD FOCUS' - BRAKES PADS AND ROTORS SHOULD NOT WEAR OUT MONTHLY. I CANT AFFORD THE REPAIRS BUT I CANT AFFORD TO HAVE MY BRAKES GO OUT COMPLETELY AND RISK THE HARM TO MYSELF AND OTHERS ON THE ROAD. PLEASE HELP *TR

DT*: THE CONTACT STATED WHILE APPLYING THE BRAKES, THERE IS A METAL TO METAL SOUND. AT 10,000 MILES THE PADS WERE REPLACED. THE VEHICLE IS MAKING THE SAME METAL TO METAL NOISE AGAIN. AN INDEPENDENT MECHANIC DETERMINED THE OUTER PADS WERE AT 35%, BUT THE INNER BRAKES WERE METAL TO METAL. THE PADS WERE REPLACED A SECOND TIME.

DT*: THE CONTACT STATED THERE WAS A RUMBLING NOISE COMING FROM THE FRONT BRAKES AT VARIOUS SPEEDS. THE DEALERSHIP DETERMINED THE FRONT BRAKE PADS WERE WORN OUT ON THE INNER SIDE AND ONLY HALF WORN ON THE OUTER SIDE. BOTH THE PADS AND ROTORS WERE REPLACED. 06/01/06 UPDATED - CONSUMER BELIEVES BRAKE CALIPERS ARE DEFECTIVE. *TT

IN APRIL I HAD MY 30,000 MILE MAINTENANCE CHECK-UP. AT THE END OF NOVEMBER MY SPEEDOMETER FAILED AND I TOOK MY CAR TO THE DEALERSHIP. I WAS TOLD I NEEDED MY BRAKE PADS REPLACED, WHICH I AGREED TO. THEY ALSO REPLACED MY ROTORS. WHEN I QUESTIONED THE DEALERSHIP WITH REGARD TO THE ROTOR WEAR, WHICH I COULD NOT UNDERSTAND SINCE I HAD THE CAR INSPECTED 3,000 MILES EARLIER AND THE BRAKES WERE FINE, I WAS TOLD THAT THIS KIND OF WEAR IS NORMAL ON THIS VEHICLE, AND TO EXPECT TO HAVE TO REPLACE MY PADS AND ROTORS EVERY 15,000 MILES. THIS PROBLEM IS A SAFETY HAZARD AND NEEDS TO BE RESOLVED. IN ADDITION, I FOUND OUT TODAY THAT THERE ARE TWO TSB'S (16685/17278) ADDRESSING THIS ISSUE. *JB

MY 2003 FOCUS ZTW WAGON HAS BEEN IN FOR BRAKES 3 TIMES IN THE LAST YEAR. FORD STANDING BY THIS AS A "WEAR" ITEM NOT COVERED UNDER WARRANTY. COULD I HAVE 2002 PARTS IN MY VEHICLE? I HAVE HAD BRAKE INSPECTIONS DONE WITH OIL CHANGES INDICATING EVERYTHING IN THE "GREEN ZONE". THE ROTOR WARPING IS SUDDEN AND UNPREDICTABLE. 3 BRAKE JOBS IN ONE YEAR IS EXCESSIVE AND PROBLEMATIC. I DO NOT FEEL SAFE IN THIS VEHICLE EVEN WITH THE BRAKES BEING FIXED. *JB

TE CONSUMER IS EXPERIENCING A PROBLEM WITH EXTENDED STOPPING DISTANCE WHEN APPLYING THE BRAKES IN A SUDDEN STOP. INTERMITTENTLY THE PEDAL WOULD FEEL SOFT WHEN THIS OCCURRED. THE VEHICLE HAS BEEN TO THE DEALER ON SEVERAL OCCASIONS AND THEY WERE UNABLE TO LOCATE A PROBLEM. *JB

I PURCHASED THIS CAR IN SEPT. 2003, BRAND NEW. THIS SPRING, WITH ONLY 23000 MILES ON IT, THE CAR BEGAN MAKING AN AWFUL GRINDING NOISE. I TOOK IT TO THE DEALERSHIP THE NEXT DAY, AND THEY HAD TO REPLACE THE FRONT ROTORS, AT A PRICE TAG OF NEAR $400. OF COURSE MY WARRANTY DID NOT COVER IT. I AM VERY DISAPPOINTED IN THIS CAR, AND IN FORD FOR SELLING A CAR THAT OBVIOUSLY HAS A FAULTY, POORLY MADE BRAKING SYSTEM. ONLY 4 MONTHS AFTER THE INITIAL REPAIR, I HAVE BEGUN HAVING PROBLEMS WITH THE CAR AGAIN. I WILL ABSOLUTELY NEVER PURCHASE ANOTHER FORD AGAIN. I AM VERY UNIMPRESSED WITH THEM. *NM

I CURRENTLY HAVE A 2003 FORD FOCUS, WHICH IN GENERAL HAS BEEN A PRETTY GOOD CAR TO ME, IF YOU TAKE AWAY THE WORRIES I'VE HAD ABOUT STOPPING! THE BRAKES HAVE SQUEAKED SINCE ABOUT 6 MONTHS AFTER I GOT THE VEHICLE (BRAND NEW) AND WHEN I TOOK IT IN THEY SAID THE PADS AND THE ROTORS WERE GONE. NOT SURPRISED SINCE I HAD GRINDING AND SQUEAKING, BUT YET AMAZED THAT THE CAR WAS SO NEW WITH SO LITTLE MILES AND THE BRAKES ARE ALREADY HAVING AN ISSUE. WHEN THE CAR WAS FINISHED, IT DIDN'T SQUEAK OR GRIND FOR A COUPLE OF DAYS - BUT THEN WENT RIGHT BACK TO GRINDING AND SQUEAKING. I TALKED TO ANOTHER GIRL WITH AN 03 FOCUS WITH THE SAME ISSUES. WHY CAN'T ALL OF US WITH THE 2003 FORD FOCUS GET TOGETHER AND COMPLAIN TOGETHER? I AM STILL WORRIED EVERYTIME I DRIVE IT THAT ONE DAY IT WON'T STOP OR SOMETHING. THIS SHOULD NOT BE AN ISSUE, FOR I PAY FOR THIS VEHICLE EVERY MONTH AND IT SHOULD BE SERVICED CORRECTLY. I ALSO ENCOUNTER MANY FORD ENGINEERS IN DEARBORN MICHIGAN THAT SAY THEY HAVE HEARD MANY REPORTS SUCH AS THIS. CAN I ASK WHY NOTHING HAS BEEN DONE ABOUT IT? THEY SAY THAT THE NEWER MODELS HAVE BETTER BREAK SYSTEMS... HOW DOES THAT HELP THE 2003 MODEL OWNERS?????? SOMETHING SHOULD BE DONE ABOUT THIS. *JB

WHEN BRAKING AT LOW SPEED THERE WAS EXTENDED STOPPING DISTANCE. DEALERSHIP REPAIRED THE FRONT/REAR BRAKE SYSTEM. *AK THE BRAKES VAVE CONSUMER PROBLEMS SINCE THEY BROUGHT THE CAR. HAD NEW ROTORS, NEVER STOPPED LIKE THEY SHOULD. FINALLY ALL THE BRAKES WENT OUT. DEALER KEPT SAYING THEY KEPT GETTING THE WRONG PARTS. STILL DON'T DRIVE AS IT SHOULD. DEFECTIVE MASTER CYLINDER. *BF

WHILE APPLYING THE BRAKES A LOUD SQUEAKING NOISE CAME FROM THE VEHICLE. DRIVER TOOK THE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT LEFT AND RIGHT BRAKE PADS AND ROTORS NEEDED TO BE REPLACED DUE TO CORROSION. *AK

VEHICLE WAS TAKEN TO DEALER FOR REGULAR CHECK UP, AND RESULTS SHOWED THAT THE ROTORS NEEDED TO BE REPLACED BECAUSE THEY WERE WORN OUT. CONSUMER WILL NOTIFY MANUFACTURER.*AK

ABS BRAKING LIGHT APPEARED ON THE DASHBOARD AND REMAINED. DRIVER NOTICED THAT WHILE APPLYING THE BRAKES THE PEDAL WENT TO THE FLOOR, AND VEHICLE SKIDDED OFF THE ROAD. DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE. TOOK THE VEHICLE TO THE DEALER FOR INSPECTION, BUT MECHANIC COULD NOT DUPLICATE THE PROBLEM . *AK

I HAVE HAD TWO FRONT END ALIMENTS IN 20,000 MILES AND MY CAR HAS 23.454 MILES ON IT . ALSO NOW IT NEEDS NEW BRAKES AND ROTORS AND THEY REFUSE TO REPLACE THEM UNDER WARRANTY . THIS IS AN ONGOING PROBLEM WITH FORD FOCUS THAT SHOULD BE FIXED . *NM

18,000 MILES ON A 2003 FORD FOCUS AND THE BRAKE PADS AND ROTORS ARE RUINED, THE DEALER TOLD ME I CAN EXPECT THIS WITH A FOCUS OR A ESCAPE BECAUSE OF CENTER MOUNTED ROTORS. THE CAR WAS INSPECTED BY THE DEALER 2500 MILES AGO. STATE POLICE CAN'T HELP ME DUE THE TIME THAT HAS PASSED SINCE INSPECTION. *AK

I HAVE A 2003 FORD FOCUS ZX5. BOUGHT IT BRAND NEW IN 1/2004. REAR BRAKES HAVE BEEN SQUEALING FOR 2 MONTHS NOW. I'VE TAKEN IT TO A FORD DEALER AND A BRAKE SHOP AND BOTH HAVE SAID THE BRAKES ARE FINE. NOW THERE IS A DEFINITE SPONGY FEEL IN THE PEDAL AND A LOUD CREAKING NOISE FROM THE BACK, AND FINALLY YESTERDAY WHEN I DEPRESSED THE PEDAL TO STOP, THE BRAKES DID NOT WORK AT ALL FOR ABOUT 5 SECONDS. I NEARLY STRUCK A PEDESTRIAN CROSSING IN FRONT OF ME. *JB

BACK AT ABOUT 18000, I TOOK MY CAR TO THE DEALER TO HAVE THE BRAKES CHECKED. THEY WERE SQUEAKING AND HAD EXCESSIVE DUST ON RIMS. AT TIMES I WOULD GET A GRINDING NOISE. THEY SAID "ALL WAS FINE." I TOOK MY CAR BACK AGAIN WITH THE SAME ISSUES, AT ABOUT 20000 MILES AND WAS TOLD THAT I NEEDED NEW BRAKES AND SINCE THE ROTORS WERE "SO THIN" THEY NEEDED TO BE REPLACED ALSO. I ASKED ABOUT THE SERVICE BULLITEN THAT IS OUT ON THIS ISSUE AND WAS TOLD THAT "FORD" WAS NOT GOING TO REPLACE THEM. I AM MAD BEYOND BELIEF THAT THERE IS A "BULLITEN" ON THIS ISSUE AND THEY REFUSE TO FIX IT. THIS NEW OF CAR SHOULD NOT HAVE GONE THREW THE BRAKES THIS QUICK. THAT IS EXACTLEY WHAT I WAS TOLD ON MY INDEPENDENT EVALUATION. NOW I AM STUCK PAYING FOR THIS EVEN THOUGH FORD IS WELL AWARE OF THIS PROBLEM.*AK

I PURCHASED A 2003 FOCUS FROM A DEALER WHO HAD USED IT FOR A DEMONSTRATION VEHICLE. THE CAR WAS OBTAINED ON OR ABOUT MARCH OF 2004 WITH ABOUT 5,600 MILES. AT THE TIME THE BRAKES SEEMED FINE. TWO WEEKS AGO I HEARD A NOISE AT 16,800 MILES. WHEN I PULLED THE WHEELS TO INSPECT THE BRAKES, I FOUND THE INNER DISC PADS DOWN TO METAL AND THE OUTER PADS WITH ABOUT 1/8 - 1/4" REMAINING. THE ROTORS ARE SCORED ON BOTH SIDES. HOW IS THIS POSSIBLE? I HAD THE SAME PROBLEMS WITH MY TAURUS. ANYONE ELSE HAVING THESE KIND OF PROBLEMS? I AM STARTING TO THINK THAT THERE IS A DEFINITE PROBLEM WITH FORD'S FRONT DISC BRAKES, OR THAT THE READ DRUMS ARE HOPELESSLY UNDER POWERED.*AK

FORD FOCUS 2003 ROTORS WEAR OUT INCREDIBLY FAST.. TOOK MY CAR IN FOR A 30,000 INSPECTION AND HAD TO HAVE NEW ROTORS AND BREAKS I WAS TOLD THAT MANY FOCUS'S ARE COMING IN AT 30,000 THAT NEED NEW ROTORS. WHY??? UNLESS THEY ARE DEFECTIVE IN THE FIRST PLACE.

MY CAR WHEN FIRST BOUGHT ALWAYS MOANED AND GROANED UPON BRAKING. I BOUGHT MY CAR 9/14/2003. THE NEXT YEAR IN 5/22/04 THE ROTORS AND PADS HAD TO BE REPLACED WITH ONLY 3,500 MILES ON IT. THE DEALER DID PAY FOR AFTER A RUN AROUND. I HAD TO WAIT A WEEK BEFORE BEING ABLE TO TAKE MY CAR IN AND WAS TOLD BY THE SERVICE ADVISOR TO NOT DRIVE MY CAR. HERE I AM IN DECEMBER NOISE IS BACK AND ROTORS ARE ALL BUMPY AGAIN WITH ONLY 8,100 MILES ON IT. THE DEALERSHIP IS WORKING ON TAKING CARE OF IT BUT I AM GOING TO FILE A DISPUTE WITH FORD MOTOR COMPANY .*AK

WHILE APPLYING THE BRAKES, THE PEDAL WENT TO THE FLOOR. THE DRIVER HEARD A LOUD SQUEAKING NOISE COMING FROM THE FRONT. THE MECHANIC INFORMED THE CONSUMER THAT THE BRAKE PADS AND ROTOR NEEDED TO BE REPLACED. THE CONSUMER TOLD THE MECHANIC THAT THIS PROBLEM HAS OCCURRED MORE THAN ONCE AND THE PROBLEM STILL HAS NOT BEEN RESOLVED. PLEASE FILL IN ADDITIONAL INFORMATION. *JB

2003 FORD FOCUS - FRONT BRAKES CAUSED OVERHEATING OF ROTORS AND SEVERE WEAR OF PADS - AT 20,000 MILES. *AK