2012 Hyundai Elantra Suspension

The contact owns a 2012 Hyundai Elantra. The contact initially received a recall notification from Hyundai Motors of America for an underbody corrosion preventative service. The vehicle was taken to the dealer where the contact was provided a list of repairs that needed to be performed on the vehicle. The vehicle was then taken to an independent mechanic where pictures were taken to document the severity of the corrosion on the suspension. The vehicle was taken back to the dealer where a second inspection of the corrosion was performed. Pictures of the suspension were taken by the dealer and submitted to the manufacturer; and the contact was provided a priority code number by the dealer. Despite the information that was submitted to the manufacturer, the manufacturer declined the repair. The contact was provided a case number by the manufacturer. The contact had the rear brakes replaced due to the severe corrosion; however, the issue remained. The failure mileage was approximately 29,586

On 10/30/2019 as I was driving down the highway at 75 mph, my front right coil spring broke and punctured my tire. Fortunately, I was able to get to the side of the road but was not in a safe area, putting others at risk. The faulty coil spring breaking and puncturing my tire could have caused a dangerous accident. Given my high rate of speed, I am very fortunate this did not cause an accident and injure myself or others. My car needed to be towed to a tire place, who discovered the broken coil spring, before again being towed to the dealership for repair. It was diagnosed that the spring broke and bent the seat on the strut assembly. Hyundai replaced my front right strut and spring under warranty but did not compensate for the destroyed tire to be replaced. On 2/6/2023 my other coil spring (left front) snapped as well. Fortunately it was where I park outside of my house so no tire was punctured and a potential accident was avoided. I just noticed it on the ground when I got out of my car. Hyundai has issued a front coil spring recall but only recalled a small window of manufacturer dates (11/12/10 to 3/31/11) and mine is not included as it was manufactured 8/23/11. It is very unlikely Hyundai changed their coil spring just before manufacturing my car less than 5 months later. There are several people on car forums that also say their car experienced the broken coil spring but their manufactured date is outside of the recall window. The recall is due to rust being in "Salt-Belt states" which my state of MN is included. Given that now both of my coil springs have now broken as well as the other horror stories online, I firmly believe Hyundai needs to expand the recall window to include more manufactured dates and fix their faulty part to avoid a public safety risk due to a tire blow out from the faulty spring breaking.

My 2011 Hyundai Elantra with only 73,000 Miles on it was affected. Front Coil Suspension Springs cracked during winter month when road salt was being used for a big storm. I live in Northern KY almost on the Ohio border. It gets cold here and Road salt is used during the winter months which is why I believe the road salt has caused corrosion on the front coil springs .This defect has put my safety at risk as well as a passenger in my vehicle. I never received any type of recall notice ...... But see there is one. The repairs cost well over $1,000.00 . I have been doing alot of research on so many others with the same issue and according to many the recall is only for month specific manufacture date based on the date of manufacture. This is widespread far more than a few months that the vehicle was made. This is something that has slipped through the cracks and is very dangerous as I was told by the shop, In my case the edge of the broken coil spring was sharp and could have caused the tire the blow out. Could have been deadly. I am seeking a refund of the repair cost. I do have an invoice for repairs if needed as I had to repair immediately . This all happened with no warning .

The component that failed was the front driver's side spring, and the piece that broke off is available for inspection upon request. The part failed while trying to leave my driveway to go to work on the morning of Fri, 3/18/22. Had the part failed while driving on the highway, I could have had an accident and worse. The vehicle was serviced by an independent service station, and verified that the spring fractured and had replaced the struts/springs on both front sides. The part has not been inspected by the manufacturer, police, insurance reps or others. There were no warning lights, but I only heard a very loud scraping noise as I tried to exit my driveway. There were no other symptoms or warnings. Side note: There is Safety Recall on the 2011 Hyundai Elantra for the exact same issue on cars in the NorthEast US States that salt their roads in the winter. That Safety Recall is NHTSA Campaign Number: 15V629000.

I WAS DRIVING HEARD A LOUD BANG THEN I GOT HOME AND LOOKED THE STRUT COIL FRACTURED AND SNAPPED OFF AND WAS HANGING THERE

FRONT COIL SPRING (DRIVERS SIDE) FAILED, RIPPING TIRING OPEN. LUCKILY THIS HAPPENED SOME TIME AFTER I PARKED AT A SUPERMARKET CAUSING NO PERSONAL INJURY. I DID SEE ON-LINE THAT THE 2011 ELANTRA HAD A RECALL FOR SIMILAR PROBLEM

BOTH FRONT SHOCKS HAVE BROKEN DURING DRIVING AND PUNCTURED THE INSIDE OF THE FRONT TIRES, CAUSING ME TO DRIVE OFF THE ROAD. THE SHOCKS DID NOT BREAK AT THE SAME TIME (FRONT PASSENGER SNAPPED FIRST AND THE FRONT DRIVER ABOUT 6000 MILES LATER.) THE FRONT PASSENGER BROKE WHEN DRIVING ON A CITY STREET AND THE FRONT DRIVER BROKE WHILE STATIONARY IN MY DRIVEWAY. THIS VEHICLE HAS UNDER 130,000 MILES, BUT HAS BEEN IN MIDWEST WINTERS FOR AT LEAST THE PAST 6 YEARS.

WHILE DRIVING ON THE HIGHWAY AT 65 MPH THE CAR WENT OVER A SMALL BUMP AND DRIVER FELT AN ODD VIBRATING FEEL FROM THE CAR. THERE WAS A HUGE AMOUNT OF WHITE SMOKE VISIBLE IN REAR VIEW MIRROR BEHIND THE CAR. DRIVER PULLED OVER AND FOUND THE DRIVER SIDE STRUT COIL SPRING HAD BURST THRU THE STRUT MOUNT AND WAS RUBBING AGAINST THE TIRE SIDEWALL OF THE TIRE. DRIVER REPLACED THE TIRE WITH THE DOUGH NUT SPARE TIRE, WHICH WAS SMALL ENOUGH TO AVOID THE EXTENDED SPRING, AND CAREFULLY DROVE HOME. DRIVER REPLACED THE STRUT HIMSELF AS CAR HAD 170K MILES AND OUT OF WARRENTY.

THE BACK END SWAYS SIGNIFICANTLY BACK AND FORTH WHENEVER THE CAR GOES OVER AN UNEVEN BUMP IN THE ROAD (AS LONG AS BOTH SIDES DON'T HIT AT THE EXACT SAME TIME). I'VE DONE RESEARCH ON THE ISSUE, AND FOUND THAT THERE ARE HUNDREDS OF REPORTS/FORUMS ALL REPORTING THE SAME PROBLEM. MANY PEOPLE ARE REPORTING COMPLETE LOSS OF CONTROL LEADING TO CRASHES, WHICH I DO NOT FIND HARD TO BELIEVE. IT TAKES AN EFFORT, WITH GOOD DRIVING CONDITIONS TO KEEP THE VEHICLE FROM SWERVING. I CAN ONLY IMAGINE HOW EASY IT WOULD BE TO LOSE CONTROL AND GO INTO A SPIN DURING RAINY OR SNOWY CONDITIONS.

WHILE TRAVELING ON A CITY STREET AT ABOUT 20 MPH, I HIT A POTHOLE WITH MY 2012 HYUNDAI ELANTRA AND THE CAR CAME TO A STOP, AFTERWARD THE TIRE BURST. NOISE WAS A LOUD RUBBING SOUND COMING FROM THE FRONT PASSENGER WHEEL. A DEFECTIVE STRUT COIL/SPRING RIPPED AND CUT THROUGH THE INNER SIDE WALL OF THE TIRE. AAA TOWED MY CAR TO ONE OF THEIR REPAIR SHOPS. TOTAL COST OF NEW STRUTS AND TIRE WAS $895.

GOING OVER A STANDARD LOW GRADE SPEED BUMP. MY DRIVER SIDE COIL SPRING SNAPPED. THIS WAS REPLACED BY THE DEALER UNDER WARRANTY. SHOULD THEY HAVE DONE THE PASSENGER SIDE PREVENTIVELY?

IN THE LEFT REAR SUSPENSION, THE TRAILING ARM BROKE OFF WHERE THE ANTI-ROLL BAR IS MOUNTED, TO WHERE THE ANTI-ROLL BAR IS NO LONGER CONNECTED TO THE SUSPENSION. THE CLUNKING NOISE THAT RESULTED FROM THIS WAS FIRST NOTICED IN EARLY MARCH 2019, AND OCCURS WHEN GOING OVER BUMPS IN THE ROAD. THE DATE OF OCCURRENCE OF 3/1/19 IS APPROXIMATE.

WAS DRIVING CAR MADE A BANG NOISE, PULLED OVER FOUND COIL SPRING BROKE ON FRONT DRIVERS SIDE. HAD TO CALL TOLL TRUCK. CAR HAS BEEN TAKEN CARE OF IN EXCELLENT SHAPE. THANK GOD I WASN'T ON HIGHWAY GOING 55 MPH. COULD HAVE BEEN A BAD ACCIDENT AND PEOPLE COULD HAVE GOT HURT . THERE WAS NO WARNING !

VEHICLE FRONT COIL SPRINGS FAILED WHILE GOING OVER A SPEED BUMP AT LOW SPEED OF LESS THAN 10 MPH. COIL SPRINGS FRACTURED AS SEEN IN THE PHOTOS ATTACHED TO THIS WRITING. COIL SPRING FAILURE FOLLOWS A SIMILAR PATTERN TO THE COIL SPRINGS IN THE HYUNDAI ELANTRA 2011, WHICH WAS RECALLED OVER THIS ISSUE. I BELIEVE THIS FAULTY PRODUCT HAS MADE ITS WAY INTO THE HYUNDAI ELANTRA 2012 SUPPLY CHAIN. HERE IS A LINK TO A WEBSITE LISTING OTHER HYUNDAI 2012 OWNERS HAVING THE SAME FRONT COIL SPRING ISSUE. HTTP://WWW.CARPROBLEMZOO.COM/HYUNDAI/ELANTRA/FRONT-SUSPENSION-COIL-SPRING-PROBLEMS.PHP IF THIS FAILURE WERE TO OCCUR AT SPEED, PARTIAL LOSS OF CONTROL WOULD HAPPEN. IT IS CONCEIVABLE THAT DEADLY, TOTAL LOSS OF CONTROL COULD OCCUR AT SPEED.

TL* THE CONTACT OWNS A 2012 HYUNDAI ELANTRA. WHILE DRIVING 55 MPH, AN ABNORMAL NOISE WAS HEARD IN THE VEHICLE. UPON PULLING OVER AND INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE FRONT COIL SPRING PUNCTURED ONE OF THE TIRES. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST SINCE THERE WERE NO RECALLS ATTRIBUTED TO THE VIN. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

I WAS DRIVING THROUGH A STORE PARKING LOT AND WENT OVER A SPEED BUMP. MY FRONT SUSPENSION COLLAPSED. LUCKILY I WAS CLOSE TO A CAR REPAIR PLACE AND WAS ABLE TO GET IT THERE THROUGH BURNING RUBBER AND INCREDIBLY LOUD NOISE. I BOUGHT THE TIRES A MONTH PRIOR. WHOLE FRONT SUSPENSION WAS REPLACED.

MY HUSBAND BACKED THE CAR UP 3 INCHES IN OUR DRIVEWAY AND THE FRONT COIL SPRING BROKE, SHOT THROUGH THE TIRE AND THE TIRE EXPLODED. WE BOUGHT OUR 2012 ELANTRA IN OCTOBER 2011 AND APPARENTLY THERE WAS A RECALL OF THE 2011 ELANTRAS FOR THIS EXACT ISSUE FOR CARS THAT ARE OWNED IN THE "SALT BELT" / COLD WEATHER STATES WHICH IS WHERE WE LIVE, BUT THE RECALL WAS ONLY ISSUED FOR ELANTRAS MANUFACTURED BETWEEN 11/12/10 TO 3/31/11. MINE IS A 2012 WHICH WAS PURCHASED IN OCTOBER 2011AND MANUFACTURED SOMETIME BETWEEN MARCH 2011 AND OCTOBER 2011. I HIGHLY DOUBT THAT HYUNDAI, WHICH APPARENTLY DIDN'T KNOW ABOUT THE ISSUE UNTIL AN INCREASE IN WARRANTY CLAIMS ON THE ISSUE STARTED AN INVESTIGATION OF IT IN 2014, CHANGED THE FRONT COIL SPRINGS THEY WERE USING TO MANUFACTURE THE SAME CAR JUST 1 "YEAR" NEWER BETWEEN THE END OF THE RECALLED VEHICLE DATE AND THE MANUFACTURE DATE OF MY 2012 ELANTRA. I NOW HAVE TO REPLACE BOTH, RELATIVELY NEW TIRES, AND FRONT STRUTS AND SPRINGS. I BELIEVE THE RECALL SHOULD INCLUDE MORE VEHICLE YEARS SINCE THERE WOULD HAVE BEEN NO REASON FOR THEM TO CHANGE THE PARTS THEY WERE USING BETWEEN 2011 AND 2012 MODELS IF THEY WERE UNAWARE OF A PROBLEM. ALSO, A 2012 ELANTRA THAT WAS POSSIBLE MANUFACTURED IN THE RECALL TIME FRAME SHOULD ALSO BE INCLUDED IN THE RECALL.

THE FRONT COIL SPRING FRACTURED WHILE I WAS DRIVING ON A CITY STREET AND CAME INTO CONTACT WITH MY TIRE. THE COIL STARTED TO RUB AGAINST MY TIRE UNTIL IT WAS PUNCTURED. I THINK THIS MAY RELATE TO THE RECALL FOR THE 2011 ELANTRA (15V629000).

FRONT AXLES ARE LOUD WHILE DRIVING. CHANGED TO A SOFTER COMPOUND TIRE AND MADE A DIFFERENCE. HOWEVER, THE ROAD NOISE HAS BECOME LOUDER AT 77,986. TOOK VEHICLE TO SERVICE AND THEY FOUND NOTHING WRONG. THIS HAS BEEN GOING ON AROUND 20,000 MILES.

FRONT LEFT COIL SPRING BROKE AFTER GOING OVER A POTHOLE AT VERY LOW SPEED (ABOUT 15MPH). I'VE RECENTLY LEARNED THAT MANY 2011 ELANTRAS IN SALT BELT STATES/AREAS HAD A RECALL ON FRONT COIL SPRINGS AFTER SIMILAR ISSUES. I'M CONCERNED THAT THE FRONT COIL SPRINGS IN MY YEAR MAKE/MODEL (2012 ELANTRA, ALSO IN A SALT BELT STATE) HAS THE SAME ISSUE AND SHOULD BE INVESTIGATED FOR A RECALL.

BIG PROBLEM WITH THE FRONT COIL SPRING. MINE BROKE AND PUNCTURED THE NEW TIRE I HAD INSTALLED THIS YEAR. THE SPRING BROKE IN HALF. I WAS GOING OVER A SPEED BUMP LEAVING A BASEBALL STADIUM WHEN ALL THIS OCCURRED.

OUR VEHICLE IS JUST OUTSIDE OF THE PRODUCTION WINDOW THAT APPLIES TO HYUNDAI RECALL 133 REGARDING FRACTURED COIL SPRINGS. OUR RIGHT FRONT COIL SPRING BROKE, RESULTING IN THE PUNCTURING OF THE TIRE. BOTH US AND THE PREVIOUS OWNER OF THE VEHICLE LIVE AND HAVE USED THE VEHICLE IN THE DEFINED SNOW/SALT REGION. THE VEHICLE IMPACTED A POTHOLE. IMMEDIATE INSPECTION SHOWED NO DAMAGE TO TIRE OR WHEEL. DRIVER CONTINUED ON TO WORK, PARKED, AND AT THE END OF THE WORKDAY BEGAN TO DRIVE HOME. AFTER TURNING A CORNER, AN AUDIBLE "GRINDING" WAS NOTED, AND DRIVER STOPPED, LOOKING UNDER THE VEHICLE FOR LODGED DEBRIS. SECOND MOTORIST STOPPED TO ASSIST, AND AN ATTEMPT TO MOVE THE VEHICLE WAS MADE, AT WHICH POINT IT WAS NOTED THAT THE SUSPENSION WAS "OFF", AND THEY BELIEVED A PORTION OF THE BRAKING SYSTEM WAS RESTING ON THE TIRE. DRIVER PROCEEDED TO ATTEMPT TO REMOVE THE VEHICLE FROM THE ROADWAY, AND THE TURNING OF THE VEHICLE RESULTED IN THE FRACTURED COIL SPRING COMING IN CONTACT WITH THE RIGHT FRONT TIRE, LACERATING IT. RECALL 133 COVERS MODELS MANUFACTURED THROUGH MARCH 31, 2011. OUR MANUFACTURE DATE IS JUNE 20, 2011.

BOTH ORIGINAL COIL SPRINGS OF THIS VEHICLE HAVE SNAPPED DUE TO CORROSION AND COLD WEATHER CLIMATE WITHIN A YEAR OF THE OTHER. HYUNDAI WILL NOT INCLUDE IN THE RECALL BECAUSE IT IS 2012 VEHICLE. THE ISSUE IS THE SAME AS THE 2011 COIL SPRING FAILURES. THIS RECALL NEEDS EXTENDED TO THE 2012 VEHICLES AS WELL.

THE DRIVER'S SIDE COIL BROKE AND PUNCTURED THE TIRE CAUSING A BLOW OUT WHILE DRIVING 70 MPH IN THE MIDDLE LANE OF A HIGHWAY. TERRIFIED BECAUSE THE THE SMOKE AND THE INABILITY TO STEER THE CAR I WAS BARELY ABLE TO GET ACROSS THE RIGHT HAND LANE AND PARK ON THE SIDE OF THE ROAD. THE CAR WAS TOWED TO THE DEALERSHIP WHERE I HAD PURCHASED MY 2012 HYUNDAI ELANTRA. I AM THE ORIGINAL OWNER, AND HAVE ALWAYS SERVICED MY CAR AT THE DEALERSHIP. THE COIL SPRING BROKE ON MAY 27TH AND THE DEALERSHIP IS HAVING DIFFICULTY LOCATING A REPLACEMENT FOR THE COIL SPRING. I AM TOLD THAT THEY COULD POSSIBLY HAVE ONE BY JUNE 8TH. THIS FACT ALONE TELLS ME THAT MY CAR IS NOT THE ONLY ONE WITH THIS ISSUE. I AM INSISTING THAT THEY REPLACE THE PASSENGER SIDE AS WELL BECAUSE I AM CERTAIN THAT IT IS JUST A MATTER OF TIME BEFORE THAT COIL ALSO BREAKS. THE DEALERSHIP SAID THAT HYUNDAI WILL NOT COVER THE COST OF REPLACING THE SECOND COIL SPRING AS THERE IS NOTHING WRONG WITH IT. I HAVE CONTACTED HYUNDAI AND STARTED A GOOD FAITH REQUEST AND THEY ARE REVIEWING TO SEE IF THEY WILL COVER THE COST OF REPLACING THE PASSENGER SIDE. HYUNDAI HAD A COIL SPRING RECALL ON 2012 ELANTRA VEHICLES FOR ALL CARS PRODUCED PRIOR TO 3/31/2011. MY CAR WAS PRODUCED ON 6/9/2011 JUST MISSING THE RECALL CUT OFF DATE. OBVIOUSLY GIVEN WHAT HAPPENED TO MY CAR THEY NEED TO EXTEND THAT CUT OFF DATE. I AM VERY LUCKY THAT MY BLOW OUT DID NOT CAUSE AN ACCIDENT. MY DEALERSHIP HAS BEEN VERY GOOD DURING THIS ORDEAL AND HAS PROVIDED ME WITH A LOANER CAR.

TL* THE CONTACT OWNS A 2013 HYUNDAI ELANTRA. WHILE DRIVING OVER A BUMP, TAR, OR ROUGH PAVEMENT, THE REAR OF THE VEHICLE WOULD BECOME UNSTABLE AND SWAY VIOLENTLY FROM SIDE TO SIDE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE AN ALIGNMENT WAS PERFORMED, BUT THE FAILURE CONTINUED. DUE TO THE FAULTY SUSPENSION SYSTEM, THE TIRES WOULD BECOME WORN AT AN ACCELERATED RATE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 750.