2003 Kia Sorento Steering

TAKATA RECALL THE CRANKSHAFT PULLEY BOLT KEEPS COMING LOSE AND THIS CAUSES THE STEERING WHEEL TO BECOME STIFF. THIS HAPPENED IN THE MIDDLE OF TRAFFIC AND HAD TO GET IT TOWED TO A FRIENDS HOUSE. CURRENTLY THE CAR IS NOT DRIVEABLE FOR OVER TWO WEEKS.

I WAS DRIVING AT 60 MPH AND MY POWER STEERING WAS GETTING HARD ALMOST CAUSE AN ACCIDENT IN THE EXPRESSWAY, I CHECK POWER STEERING FUEL AND IS FINE, BELT TO POWER STEERING FINE TOO, I JUST WONDER IF THERE IS A RECALL PARTS IN THIS PROBLEM, IM VERY AFRAID TO DRIVE MY KIA AGAIN, PLEASE INVESTIGATE. *TR

I HAD JUST PURCHASED MY 2003 KIA SORENTO ON FEBRUARY 23 2013 FROM A LOCAL USED CAR DEALER. THE CAR HAD 85,000 MILES AT TIME OF PURCHASE. IT WAS DRIVING FINE UNTIL MARCH 31, 2013. AS I WAS PULLING OUT OF MY DRIVE WAY THE CAR STARTED MAKING A LOUD NOISE AND THEN I LOST CONTROL OF THE STEERING ALMOST GOING INTO MY NEIGHBORS DITCH. THE CAR WAS TAKEN TO THE MECHANIC(TOWED) WHERE HE FOUND THAT THE BOLT GOING INTO THE CRANK SHAFT HAD BEEN SHEARED OFF CAUSING THE BELT TO COME OFF. THE PROBLEM IS THAT EVEN AFTER HE FIXES IT (1800.00 +) HE SAID IT WOULD HAPPEN AGAIN.THIS IS A VERY DANGEROUS PROBLEM. AFTER READING COUNTLESS ACCOUNTS ONLINE OF OTHER KIA SORENTO OWNERS WITH THE SAME PROBLEM, I FEEL KIA NEEDS TO RECALL THIS PART. *TR

TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT WAS DRIVING 5 MPH AND ATTEMPTING A TURN WHEN THE STEERING WHEEL FAILED AND WOULD NOT RESPOND TO THE DIRECTION IT WAS TURNED. THE STEERING WHEEL WOULD ONLY SPIN IN A CIRCLE DURING THE FAILURE. THE VEHICLE WAS PLACED IN REVERSE AND ALLOWED TO DRIFT INTO THE PREFERRED PARKING SPACE. THE VEHICLE WAS DIAGNOSED BY A PRIVATE MECHANIC WHO ADVISED THAT THE U JOINT WAS LOOSE ON THE STEERING SHAFT. THE MANUFACTURER WAS CONTACTED, BUT THE VEHICLE WAS NOT TAKEN TO THE DEALER OR REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 93,000.

TL*THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING THE STEERING WHEEL LOCKED AND COULD NOT TURN LEFT OR RIGHT. THE MECHANIC STATED THAT A BOLT AND BALANCER DETACHED FROM THE HINGES. THE CONTACT SUGGESTED THAT THE POWER STEERING MAY HAVE BEEN LOW IN FLUID. THE CURRENT AND FAILURE MILEAGE WERE 79,000.*AK

2003 KIA SORENTO WITH HISTORY OF POWER STEERING FAILURES WHICH RESULTED IN NO POWER STEERING ASSISTANCE WHILE TURNING AT LOW SPEEDS. PROBLEM FIXED MAY 2004 (AFTER THEE VISITS TO DEALER) ALTHOUGH TSB IDENTIFYING CORRECTIVE ACTION WAS ISSUED A YEAR EARLIER. STEERING RACK FOUND TO BE SEEPING FLUID DURING ANNUAL INSPECTION AT 63,760 MI. TAKEN TO DEALER AT 70,000 MILES FOR EVALUATION. DEALER ADVISED THAT SEALS NOT SERVICEABLE, STEERING RACK AND HOSES REQUIRE REPLACEMENT AT COST OF $2000 - NOT COVERED UNDER WARRANTY. KIA CUSTOMER SERVICE ADVISED THAT STEERING RACK COVERED UNDER WARRANTY UNTIL 60,000 MI; NOT PART OF 100,000 MI POWERTRAIN WARRANTY. I HAVE BEGUN A SEARCH FOR A NEW VEHICLE, AND KIA PRODUCTS AREN'T ELIGIBLE FOR CONSIDERATION. *NM

2003 KIA SORENTO WOULD LOOSE POWER STEERING ASSISTANCE WHEN TRANSITIONING FROM MODERATE SPEEDS (30-50 MPH) TO LOW SPEED (5-10 MPH), SUCH AS WHEN EXITING A HIGHWAY BY SLOWING IN A CENTER TURNING LANE AND TURNING LEFT IN FRONT OF ONCOMING TRAFFIC. FIRST OCCURANCE WAS AT 19,000 MILES (SEPT 2003), KIA DEALER WAS UNABLE TO REPLICATE PROBLEM AND RETURNED THE VEHICLE TO ME. PROBLEM CONTINUED INTERMITTENTLY UNTIL 30,000 MILES (MAY 2004) WHEN I RETURNED TO DEALER AND THEY DISCOVERED A TSB ON THIS ISSUE. DEALER REPLACED P/S SENSOR AND LOADED IMPROVED SOFTWARE CODE. THERE WERE A NUMBER OF NEAR COLLISIONS DUE TO THIS FAILURE. *NM

ONGOING PROBLEMS WITH POWER STEERING. FEELS LIKE ENGINE IS STALLING AND POWER STEERING IS LOCKING UP WHEN MAKING TURNS AT LOW SPEED. VERY DIFFICULT TO STEER. THIS HAPPENS INTERMITTENTLY. *JB

I PURCHASED THE SORENTO 5/31/03, WHILE MAKING A RIGHT HAND TURN THE POWER STEERING COMPLETELY WENT OUT; I ALMOST HIT ANOTHER VEHICLE REGAINING CONTROL. CONTACTED KIA CONSUMER AFFAIRS IMMEDIATELY, THEY HAVE COMPLETE LOGS ON FILE. 6/2/03 DEALER REPLACED POWER STEERING RACK. 6/10/03 830 MILES,POWER STEERING FAILED AGAIN;HAD TO FIGHT WITH THE STEERING TO CONTROL VEHILE IN PARKING GARAGE.6/12/03 POWER STEERING PUMP WAS REPLACED. PICKED UP VEHICLE THAT EVENING AND PULLING OUT FROM THE RESTAURANT THE POWER STEERING WENT OUT AGAIN. 6/13/03 850 MILES, COMPUTER MALFUNCTION; NEW DOWNLOADS HAD TO BE DOWNLOADED TO VEHICLES COMPUTER. 6/18/03 ELECTRONIC POWER STEERING MODULE HAD TO BE REPLACED. NOW 6/20/03 DEALER SAID THEY WONT HELP ME, KIA CONSUMER AFFAIRS SAID THEY WONT REPLACE THE VEHICLE NOR BUY BACK THE VEHICLE. I'M TERRIFIED TO PICK UP THE VEHICLE TONIGHT. KIA WANTED ME TO DRIVE THE VEHICLE 30 DAYS MORE THEN CALL BACK AND THEY WILL RE-IMBURSE ME 2 MONTHS PAYMENTS FOR ALL THE TROUBLE. I REPLIED I WONT DRIVE IT, I'LL HAVE IT FLAT BEDDED TO MY HOUSE AND SEEK LEGAL COUNCIL.

INTERMITTENTLY POWER STEERING FAILED, MAKING HARD TO DRIVE THE VEHICLE. *AK

BOUGHT CAR NEW. POWER STEERING NEVER WORKED. NEEDED TO BE REPLACED. *LA

PURCHASED 2003 KIA SORENTO 4X4 ON 5/26/03. ON 5/31/03 (ODOMETER 600 MILES)WHILE DRIVING AND MAKING A RIGHT HAND TURN THE POWER STEERING FAILED, ALMOST STRUCK ANOTHER VEHICLE, TRIED TO REGAIN CONTROL OF VEHICLE AND PULLED TO SIDE OF ROAD. A FRIEND WAS IN THE VEHICLE WITH ME AND CAN ATTEST TO THE POWER STEERING FAILURE BECAUSE HE TRIED TO STEER THE VEHICLE ALSO. 6/2/03 DEALERSHIP REPLACED POWER STEERING RACK, GEAR AND ASSEMBLY. ON 6/10/03 (ODOMETER 830) POWER STEERING FAILED AGAIN WHILE I WAS EXITING DOWN IN A PARKING GARAGE; HAD TO FIGHT WITH THE STEERING WHEEL TO GAIN CONTROL. ON 6/12/03 (ODOMETER 850) POWER STEERING PUMP WAS REPLACED AND LATER THAT EVENING WHILE PULLING OUT OF A PARKING STALL FROM THE RESTAURANT THE POWER STEERING WENT OUT AGAIN. DEALERSHIP SAID A TEAM OF 3 KIA SERVICE TECHS NOW FOUND OUT THERE WAS A PROGRAM ERROR ON THE VEHICLES COMPUTER; THEY CAME TO THE CONCLUSION THEY(KIA OR THE DEALERSHIP) DIDN'T HAVE A CLUE. MONDAY 6/16/03 ENGINEER TEAM FROM KIA WAS TO EVALUATE THE VEHICLE. THEY COULD NOT FIGURE THE PROBLEM OUT. AFTERNOON OF 6/16/03 DEALERSHIP SAID KIA'S FIELD INSPECTOR WILL BE OUT WEDNESDAY 6/18/03 TO EVALUATE THE VEHICLE FURTHER. I COULD HAVE KILLED SOMEONE OR MYSELF DRIVING THIS VEHICLE WHILE THE POWER STEERING REPEATED FAILED. NOW I'M DEATHLY TERRIFIED DRIVING THE VEHICLE, I'M IN A RENTAL CAR UNTIL WEDNESDAY 6/18/03 WHILE THE KIA FIELD INSPECTOR EVALUATES THE VEHICLE. IN MY OPINION KIA NEEDS TO RECALL THIS VEHICLE AND GIVE MY MONEY BACK. I DON'T NEED TO RISK MY LIFE IN ORDER TO MAKE THE COMPANY LOOK GOOD. KIA CONSUMER AFFAIRS WERE KEPT IN THE LOOP FROM DAY ONE BUT NO ONE CARES HOW SERIOUS THIS IS, PLEASE HELP. *NLM