2018 Tesla Model 3 Air Bags

Safety Restraint Warning appeared on a 50k miles Tesla Model 3. We are a used electric vehicle dealer in California. This warning has been appearing on parked vehicles repeatedly. Meaning, many of the Model 3's we have listed for sale (over 30 units for sale at any given time) will suddenly have a "Safety Restraint Warning" appear. Tesla is not taking responsibility for this. They always charge the customer. The airbag system is inoperable with this warning. It's a problem on EVERY Model 3 on the road between the year of 2017 to 2020.

I have an active alert on the drive side safety restraint system. Alert code RCM_a021. I have noticed this appears to be a common problem. A recall should be issues as this a a safety issues and lives could be at stake.

The contact owns a 2018 Tesla Model 3. The contact stated that while driving at approximately 30 MPH through an intersection, another vehicle t-boned the driver's side from the driver's side front bumper to the rear passenger door. The contact stated that the air bags did not deploy as intended. Medical attention was needed after the contact sustained lower back, left shoulder, neck, tailbone, and internal bleeding injuries were sustained. A police report was filed. The vehicle was taken to a collision center, where it was currently pending an inspection. The manufacturer was not notified of the failure. The failure mileage was approximately 88,894.

Passenger restraint fault message randomly comes on.

The car's dashboard display shows an alert "Front Passenger Safety Restraint System Issue". This puts the front passenger at risk.

My 2018 Tesla Model 3 began showing a "front passenger safety restraint fault" alert within the last week or so. I scheduled service and then received an estimate of almost $1000. When I corresponded with Tesla through their app, they told me the diagnostic code is: RCM_a056_passengerFrontOCS, indicating failure of the passenger Occupant Classification System (OCS). The OCS controls whether and how the airbag deploys; failure could prevent deployment or cause improper deployment in a crash, creating a serious safety risk. Tesla acknowledges the fault but told me the repair (replacing the OCS and passenger airbag) will not be covered since the car is out of warranty. Tesla has issued service bulletins (SB-19-20-003 R1, SB-23-20-002 R7) for known OCS issues, and many Model 3 owners have reported the same fault. This appears to be a widespread safety defect and should be investigated as a potential recall.

Vehicle is displaying an error message "Front passenger safety restraint system fault" and "front passenger safety restraint system fault. Service is required." This has the result of "The restraint system may not function as designed." According to an Internet search, this is a very common fault, caused by "interference" and necessitates an occupancy sensor, wiring harness and airbag module exchange.

I received and indicator noting that my front passenger safty system has a fault. They indicated that they will have to replace the seat sensor and the airbag. I believe this to be an innate fault of the cars construction. It is dangerous and should be fixed by Tesla and not charged to the customer.

I received an onboard alert that says ‘Safety Restraint System Issue/Service is required.’ According to online Tesla Forums, this is a very common issue with the Model 3 drivers side air bag system. Although some relate it to a wire under the seat that becomes worn with movement of the seat, Tesla gives an estimate of over $1,000 to fix the problem. There repair estimate involves updating the front passenger airbag ($444), and replacing the occupant classification system ($426).

This is a widespread safety issue that requires a recall! This is not isolated. Model 3 passenger airbags are at risk of not deploying. Car alert: Update Front Passenger Airbag to Maintain Compatibility with Front Passenger Seat Remedy: “Replace Front Passenger Airbag And Update Vehicle Configuration”

The vehicle showed an alert "Front passenger safety restraint system fault/Service is required". The vehicle never had an accident, nor abnormal usage, which may have caused this system fault. The manufacturer's service department gave a repair plan including an air-bag replacement at the owner's cost. It is not fair to force vehicle owners to be responsible for the cost to repair the manufacturer's safety system problem. The repair should be done under a safety recall.

Two recent incidents/repairs related to both driver and passenger Curtain Airbag, replacement of Occupant Classification System, replacement of first row seat cushions, first row harness assembly, first row occupancy sensor, first row seat belt reminder sensor box. Total out of pocket cost of approximately $2,075!

Front Passenger Safety Restraint System Fault continually chimes and then goes away again. Appears to have loose or faulty wiring. This is directly related to the passenger airbag system, so very concerning. -Tesla inspected this back in March 2020, with no repair, -Inspected it again in August 2020 and found an error related to the left curtain airbag connector and repaired under warranty using a Wire harness Repair Kit. -Same fault started again in 2023. Tesla recommended bringing into the shop for inspection and is quoting $800 to repair, so I have not taken it in yet as I believe this is a manufacturing defect that I should not have to pay for.

Front Passenger Safety Restraint System Fault​. My airbags are faulty and I'm having to replace them at full price. Ive never hit anything and never been in an accident.

Error message in passenger airbag restraint system. There is a known issue where the cable bundle in the seat wears with movement of the seat, causing a short. Tesla has redesigned the bundle and it’s using a new airbag, but will only replace the faulty bundle if it fails while under warranty. It is a >$1900 Repair for the customer. Upon my research, this happens frequently even in the first year of the car. My car has 39,000 miles on it is faulty already. They can’t replace the bundle because the new Improved bundle requires a different airbag, increasing the cost of the consumer

For the fifth time since the car was purchased new, it is displaying a warning that there is a passenger airbag fault. This has been repaired previously four times by Tesla, on 8/04/20 (28980 miles, replace OCS filter module), 2/10/21 (35831 miles, replace front passenger seat), 1/06/22, and 5/08/23 (52891 and 82293 miles, both replace OCS filter module). It is now showing this warning again (106507 miles, 8/22/24) for the fifth failure. This is extremely concerning that an airbag may not deploy properly or even might deploy when not warranted. Since the car has been repaired so many times for the same recurring problem it suggests there is a systemic issue with this component which should be addressed properly.

My Tesla has been displayed a warning error message "Front passenger restraint system fault". This is a safety issue, I searched online and it looks like this is a common problem for the 2017-2019 Tesla Model 3. Many of the owners were fortunate if the issue happened before the expiration of the warranty which Tesla fixed it for free. However, this issue happened after warranty expired. I took the car to service center, they estimated the fix would cost over $3200 (see attached). Tesla claimed that the fraudulent module cannot be replaced as it's no longer support the older version of the airbag system. To fix the problem, it will have to replace the airbag, seat cushion and harness system. This is clearly a defect with the original equipment where manufacture does not support or provide replace with original parts.

My 2018 Tesla Model 3 is experiencing an intermittent "Front Left Safety Restraint System Fault". This error message, appearing on the main display, suggests an issue with the driver-side airbag, seatbelt pretensioner, or related components. The fault seems unrelated to seat occupancy or weight, as it occurs both with and without a passenger. While the error message eventually disappears after restarting the vehicle, its recurring nature is concerning and raises safety concerns about the airbag deploying unnecessarily or failing to deploy in an actual collision. This problem appears similar to those reported by other Tesla Model 3 owners, suggesting a potential systemic defect in the safety restraint system that warrants further investigation by the NHTSA. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

First. the car gives Front Restraint System Fault message and Tesla fixed during warranty. No, it's out of warranty, and the car starts giving Front Passenger Restraint System Fault warning message. Regardless if it's under warranty or not, restraint system fault (I take it as seat belt) imposes safety concern and should be a recall item.

I'm receiving an error "Front Passenger Restraint System Fault". According to online forums, this issue is PREVALENT amongst many Tesla vehicles. This seems like a serious defect that Tesla should be responsible for fixing.

Safety Restraint System fault warning, passenger airbag off on display. 1) 4/10/24 Dealer replaced Occupant Classification System components for front passenger seat for $184.26. Dealer assured issue being resolved. 2) 5/5/24 Same fault warning, passenger airbag off on display reappeared for 2nd time and dealer replaced front passenger airbag for $1089.18. Dealer assured issue being resolved. 3) 5/10/24 Same fault warning, passenger airbag off on display again reappeared for 3rd time and dealer is now proposing to replaced front passenger seat back and seat cushions for $1248.07.

Airbag failed at 60k miles requiring a replacement. This is a known- safety issue, Tesla has corrected this problem in later cars, and Tesla should issue a recall to correct. I have error codes RCM_a015 and RCM_a014

My car has 98,000 miles and out of warranty. When driving 10 days ago I saw a message on the screen "Front Passenger Restraint System Fault" I took the car to the Tesla Garage and was advised that it might be the air bag. They said it could cost as much as $$1,826.66. They kept the vehicle and sent a message asking me to authorise my credit card pay this amount when done. First of all I note on the Tesla Motors Club that I am not alone. Second I have to rely on Tesla being honest about this. They have their own propriety testing system so I could not take it to another mechanic. Last of all I have never experienced a failed air bag in my vehicles before and it seems that Tesla has problems and this should have been paid by them as a recall item

Front passenger airbag and Seat sensor issues. The safety of front seat passenger was at risk due to faulty airbag or sensor. Tesla did confirmed that an alert was trigger on the car an they proceeded to replaced the airbag and sensor. Tesla verified the equipment after the repairs were done and everything since to be fine. We did get a warning on or around Feb 5th, 2024 and that when we proceeded to contact Tesla service and make an appointment. The reason for this complain is that we ended up paying for airbag and seat sensor repairs which should have been covered by Tesla since these parts are obviously defective. Please see uploaded documents for more details.

My Model 3 began giving an RCM_a056 error indicating a fault with the front passenger safety restraint system. When I scheduled service for this fault at Tesla, they advised that the front passenger airbag and occupant sensor for the right/front seat needed to be replaced. Research into this issue revealed at it is a common issue. Other owners reported Tesla covering the cost of this repair (indicating they know this is a manufacturer defect in a major safety system and not a one-off issue.) Unfortunately, Tesla refused to repair this issue without payment, insisting that my SRS warranty had expired. I believe this is a manufacturer defect in a critical safety system that should be investigated for a possible recall.