2011 Toyota Tacoma Electrical System

Blower Fan had been cutting off. Only running intermittent on High. Took to Toyota dealer June 2025. Was told it was a Cabin Air Filter Clogged. Paid for replacement and clean out of system. Continued to not work. Called a mechanic and asked for a diagnostic. Was told it was a “known issue” with Toyota Tacomas. Had been a recall in later years. I ordered the blower motor resistor and wiring harness from Toyota parts department. It was on back order due to the issue being widespread. July 2025 parts came in. Returned truck to the shop. The techichian replaced the motor blower resistor and the new wiring harness. However, he cut the burnt wires off and spliced the new wires into old wires back to the motor. Aug 2025 motor has stopped working again. Back to the Toyota shop. The truck needs a new blower motor. The labor will be 1200. Plus the labor I’ve already paid for three other shop visits plus parts. The motor blower is on back order till mid September. The motor has been let unplugged due to “risk of fire”. But I’ve been given the vehicle again to drive. It has had a risk of fire since June. The wires have been overheating and smelling. This should have been a recall in 2011. Just as it was in the later Toyota Tacoma. Pleas investigate

HORN NOT WORKING .WAS TOLD IT WAS IN STEERING WHEEL

HORN STOPPED WORKING AT APPROXIMATELY 95000 MILES. SPOKE WITH TECHNICIAN AND WAS TOLD THIS PROBLEM WAS POSSIBLY RELATED TO THE AIRBAG.

MY HORN STOPPED WORKING AND MY AIRBAG LIGHT STAYS ON. I WAS TOLD THIS WAS AN SPRIAL CABLE PROBLEM IN THE STERRING WHEEL COLUM. WAS TOLD TO CHECK ONRECALLS FOR THIS HAS BEEN A PROBLEM WITH THIS TYPE TRUCK.

TL* THE CONTACT OWNS A 2011 TOYOTA TACOMA. WHILE DRIVING AT VARIOUS SPEEDS, THE FAN STOPPED WORKING. THE CONTACT ALSO SMELLED AN ABNORMAL BURNING ODOR COMING FROM THE VEHICLE. THE CONTACT CHECKED BEHIND THE FIREWALL AND THE WIRING HARNESS AND WIRING WERE BURNED. THE CONTACT STATED THAT THE DAY TIME RUNNING LIGHTS WERE MELTING ALONG WITH THE FIXTURES AND WIRES IN THE BACK OF THE BULB. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT'S DIAGNOSIS WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2011 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, HE COULD SMELL A BURNING ODOR COMING FROM UNDER THE DASHBOARD AREA. THE VEHICLE WAS MERGED TO THE SHOULDER AND SUDDENLY BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS CALLED, WHO ARRIVED AND EXTINGUISHED THE FIRE. THE ORIGIN OF THE FIRE WAS UNKNOWN. THERE WERE NO INJURIES AND THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 32,500.