2005 Toyota Tundra Suspension

The contact owns a 2005 Toyota Tundra. The contact stated that while driving at 35 MPH, the driver’s side front ball joint detached causing the front driver’s side wheel to bend inward. No warning lights were illuminated. The vehicle was towed back to the residence which caused damage to the fender. The dealer was made aware of the failure and informed the contact that the vehicle was previously repaired under NHTSA Campaign Number: 07V013000 (Suspension) however, the failure occurred. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 290,000.

Toyota did an inspection for frame rust years ago, but mine is now rusting out I believe it should have been swapped at the time of the recall.

i recently purchased the 2005 Tundra I was instructed to take the Tundra to Westbury Toyota for inspection and they didnt even took at the truck they claimed according to the VIN is not eligible for any consideration from Toyota North North America The frame has recessive deterioration. We understand the truck doesnt have lifetime warranty but I am disappointed in Toyota's response

Front left wheel fell off. What component or system failed or malfunctioned, and is it available for inspection upon request? FRONT LEFT WHEEL. YES, AVAILABLE FOR INSPECTION How was your safety or the safety of others put at risk? WHEEL FELL OFF Has the problem been reproduced or confirmed by a dealer or independent service center? YES. TOWED TO SHOP; THEY AGREED THAT FRONT LEFT WHEEL FELL OFF. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? CAPITOL BODY SHOP, RIDGELAND, MS Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? UKNOWN. VEHICLE HAS MADE NOISE OFF AND ON, BUT WHETHER DUE TO THIS I CANNOT SAY. PLEASE NOTE: THIS VEHICLE WAS SUBJECT TO Recall Number 07V013000 Recall Date 01/19/2007 lOWER BALL JOINT. THIS VEHICLE HAD THAT SERVICE DONE IN LAS VEGAS NEVADA AT APPROX 12,500 MILES. WHAT FAILED WAS THE FIXED/REPAIRED/REPLACED JOINT. ALL

I believe my Toyota frame is rusted. The truck has 56,000 miles. The front wheel has a noticeable problem with the camber - it can not be driven safely.

the frame has rotted to the point the vehicle cannot be driven. rusted with holes all in it unsafe

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED WHILE DRIVING 40 MPH, THE DRIVER'S SIDE FRONT BALL JOINT BENT UNDERNEATH MAKING THE VEHICLE DIFFICULT TO STEER. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER OR AN INDEPENDENT MECHANIC TO BE DIAGNOSED OR REPAIRED. THE CONTACT REPLACED THE PART HIMSELF. THE FAILURE RECURRED WITH THE FRONT PASSENGER'S SIDE BALL JOINT BEING BENT. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 300,000.

SIGNIFICANT FRAME CORROSION IN MULTIPLE AREAS TO INCLUDE ONE AREA WITH A HOLE ALL THE WAY THROUGH THE FRAME RAIL, AND MOST ACUTELY WHERE THE REAR LEAF SPRING CONNECTS TO THE FRAME WITH ONLY 50% OF THE CONTACT AREA APPEARING TO BE STRUCTURALLY SOUND. DEALER STATES NOTHING THEY CAN DO. TWO AUTO RESTORATION SHOPS STATE THE FRAME IS GOING TO FAIL AND CAUSE AN ACCIDENT.

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE HAVING A ROUTINE INSPECTION FOR AN OIL CHANGE THE DEALER (LOYALTY TOYOTA 2000 WALTHALL CENTER DR, CHESTER, VA 23831, (804) 796-1800) NOTICE CORROSION AROUND THE DRIVER SIDE REAR WHEEL WELL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE) AS A POSSIBLE SOLUTION TO THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED WHILE DRIVING AT 40 MPH, WHEN THE FRONT PASSENGER SIDE TIRE DETACHED AND ROLLED AWAY ON THE ROAD. THE CONTACT STATED THE FRONT PASSENGER SIDE DOOR AND FENDER HIT A CURB. THE AIR BAGS DID NOT DEPLOY. THE CONTACT STATED HE DID NOT SUSTAIN ANY INJURIES OR SEEK MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND WAS INFORMED THAT THE LOWER BALL BEARING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AS OF YET AWAITING THE PART. THE CONTACT CALLED LOCAL DEALER MAITA TOYOTA OF SACRAMENTO LOCATED AT 2500 AUBURN BLVD, SACRAMENTO, CA 95821, (916) 481-0855 AND NOTIFIED THAT THE VEHICLE WAS REPAIRED PREVIOUSLY UNDER NHTSA CAMPAIGN NUMBER: 07V013000 (SUSPENSION) BACK IN 2007. THE MANUFACTURER WAS NOT INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 330,000.

ON SEPTEMBER 30, 2019, MY 2005 TOYOTA TUNDRA (PURCHASED NEW IN 2004) DID NOT PASS INSPECTION DUE TO RUST HOLES ON THE FRAME; MILEAGE WAS 81,147. I LOOKED UP VIN NUMBER ON NHTSA AND THERE IS ONLY ONE RECALL DATED OCTOBER 2019 NOT FULFILLED FOR MY VEHICLE. A LOCAL DEALER INVESTIGATED MY VIN NUMBER, AND TOLD ME THERE WAS A D ZERO D/LIMITED SERVICE CAMPAIGN (EXPIRED 2015) REGARDING RUST PROBLEMS WITH THIS VEHICLE. I WAS NOT NOTIFIED BY TOYOTA ABOUT THIS. I HAVE NOT MOVED/CHANGED ADDRESS SINCE I PURCHASED THIS VEHICLE, AND I DID RECEIVE AND FULFILL THE 2016 AND 2007 RECALL NOTICES. I CALLED NHTSA AND TOLD THE WOMAN ON PHONE ABOUT THE D0D/LSC AND SHE FOUND IT FOR ME UNDER 'MANUFACTURER COMMUNICATIONS'. I HAVE TAKEN GOOD CARE OF IT AND HAVE ALL OF MY SERVICE RECORDS. I EXPECTED IT TO LAST AND AM DISAPPOINTED TOYOTA DID NOT NOTIFY ME. I AM REQUESTING NHTSA MAKE THESE LIMITED SERVICE CAMPAIGNS FOR VEHICLES VISIBLE WITH THE OTHER RECALLS. I LOOK FORWARD TO HEARING BACK FROM YOU AND A RESOLUTION OF THIS PROBLEM.

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE DRIVING 5 MPH, THE FRONT DRIVER'S SIDE WHEEL FRACTURED AND THE LOWER BALL JOINT FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 07V013000 (SUSPENSION). THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 07V013000 (SUSPENSION). THE DEALER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 216,000.

I WAS DRIVING MY 2005 TOYOTA TUNDRA ON THE INTERSTATE. I CAME UPON ROAD WORK AND SLOWED TO THE 45 MPH SPEED LIMIT. ALL OF THE SUDDEN THE TRUCK DROPPED TO THE FRONT LEFT WITH A LOUD CRASH. SPARKS WERE FLYING AND I LOST CONTROL OF THE VEHICLE FOR A BRIEF TIME. I WAS ABLE TO SLOW AND STEER THE TRUCK TO SAFETY. I GOT OUT OF THE TRUCK TO SEE THE FRONT DRIVERS SIDE WHEEL BUCKLED UNDERNEATH THE TRUCK AND MAJOR DAMAGES TO THAT SIDE OF THE VEHICLE. I'M VERY LUCKY TO HAVE SLOWED FOR ROAD WORK. IF I HAD OF BEEN DOING INTERSTATE SPEEDS OF 70 MPH I WOULD NOT HAVE BEEN ABLE TO HANDLE THE VEHICLE AND COULD HAVE HAD SEVERE AND FATAL CONSEQUENCES. EVERY DAY FOR THE PRIOR WEEK OR SO I NOTICED THE TRUCKS STEERING BEING WEIRD (PULLING A LITTLE TO THE RIGHT SIDE AND NOT BEING ABLE BE STEERED WITH THE NORMAL EASE) AND IT MAKING A LOUD SQUEAKING SOUND WHEN TURNING.

MY 2005 TOYOTA TUNDRA'S CONTROL JOINTS MESSED UP WHILE I WAS DRIVING.

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE DRIVING 10 MPH, THE LOWER BALL JOINT SEPARATED WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT REPLACED THE LOWER BALL JOINT. THE VEHICLE WAS THEN TAKEN TO THE DEALER (AMERICAN TIRE & WHEEL INC, 115 MALL ST, HOT SPRINGS, AR 71913) AND THEY CHECKED AND REPLACED ALL THE PARTS AT THE FRONT END OF THE VEHICLE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AT 800-331-4331 AND STATED THAT THE RECALL HAD ALREADY BEEN REPAIRED. CASE NUMBER: 1709200139 WAS PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.

THE MAIN CHASSIS HAS HAS RUSTED AND BROKEN

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE FRONT DRIVER'S SIDE TIRE. THE VEHICLE BECAME INOPERABLE AS THE FRONT DRIVER'S SIDE WHEEL DETACHED FROM THE VEHICLE. AS A RESULT, THE FRONT OF THE VEHICLE HIT THE GROUND. THE CONTACT WAS ABLE TO PULL THE VEHICLE TOWARDS THE RIGHT SIDE SHOULDER OF THE BELTWAY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE UPPER AND LOWER BALL JOINTS FRACTURED, DAMAGED THE ABS SENSOR, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. WHILE AN INDEPENDENT MECHANIC WAS INSPECTING THE VEHICLE, THE MECHANIC OBSERVED THAT THE REAR DIFFERENTIAL WAS SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING 45 MPH OVER A BRIDGE, THERE WAS A LOUD NOISE AND THE VEHICLE IMMEDIATELY LOWERED. THE CONTACT STATED THAT THE REAR DRIVER'S SIDE TIRE EXPLODED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT BOTH THE LOWER AND UPPER BALL JOINTS SNAPPED AND CAUSED THE REAR DRIVER SIDE TIRE TO EXPLODE FROM THE FORCE OF THE IMPACT. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 158,000.

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 25 MPH UP A SLIGHT HILL, THE LOWER BALL JOINT DETACHED ON THE FRONT PASSENGER SIDE. ADDITIONALLY, THE CONTACT STATED THAT THERE WAS AN INTERMITTENT LOUD ABNORMAL NOISE COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE REPAIRS WERE UNKNOWN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 07V013000 (SUSPENSION). THE APPROXIMATE FAILURE MILEAGE WAS 140,000. DR

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE BALL JOINT FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE BALL JOINTS WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 202,000. UPDATED 8/11/14*CN

TL* THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE FRONT END OF THE VEHICLE COLLAPSED. THE CONTACT NOTICED A BURNING SMELL AND SMOKE COMING FROM THE FRONT PASSENGER SIDE OF THE VEHICLE. THE CONTACT LOST CONTROL OF THE STEERING BUT MANAGED TO COME TO A STOP. THE VEHICLE WAS TOWED TO THE LOCAL MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 266,019. *TR

TL*THE CONTACT OWNS A 2005 TOYOTA TUNDRA. THE BALL JOINTS WERE REPLACED. SHORTLY AFTER THE REPAIR, WHILE DRIVING BETWEEN 5 TO 55 MPH, THE VEHICLE BEGAN PULLING TO THE RIGHT. THE VEHICLE WAS TAKEN TO THE DEALER FOR AN ALIGNMENT, BUT THE FAILURE CONTINUED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 46,000 AND FAILURE MILEAGE WAS 43,000.

RECALL ON TOYOTA TUNDRA IN 2007. THE BALL JOINTS WERE FOUND TO BE DEFECTIVE BECAUSE OF A HARDNESS ISSUE ON THE SURFACE TREATMENT OF THE BALL. THE FAILURE WOULD BE A PREMATURE WEARING OR FAILURE OF THE JOINT. TOYOTA DID ISSUE A RECALL AND REPAIRS MADE TO THE VEHICLE. AFTER THE REPAIR THE VEHICLE HAD A HARD PULL TO THE RIGHT AND VIBRATION THAT DID NOT EXIST PRIOR TO THE REPAIR. AFTER TAKING IT BACK TO THE DEALER, THEY FOUND THE STEERING WHEEL AND FRONT END OUT OF ALIGNMENT. THE DEALER REPAIRED THESE BUT DID NOT FIX THE PROBLEM. AFTER A TOTAL OF 4 VISITS OVER A 6 MONTH PERIOD THE VEHICLE STILL HAS A DANGEROUS PULL VIBRATION. THE DEALER CANNOT REPAIR THE PROBLEM. *TR

2005 TOYOTA TUNDRA RECALL ON LOWER BALL JOINTS. CONSUMER WOULD LIKE INFORMATION ON MAKING AN APPOINTMENT WITH THE DEALER. *KB