2002 Ford F-150 Power Train

ROUGH IDLE.*AK

VEHICLE LOST MOTION INTERMITTENTLY WHILE DRIVING 0-40 MPH AND WHEN THE CLUTCH WAS BEING ENGAGED. VEHICLE WAS TAKEN TO THE DEALER, WHO FOUND THE CLUTCH SLAVE CYLINDER WAS LEAKING FLUID. *AK

VIBRATION IN DRIVETRAIN AT HIGHWAY SPEED (BETWEEN 65 -75 MPH). ONLY HAPPENS WHEN TRUCK IS UNDER POWER. AS SOON AS YOU REMOVE YOUR FOOT FROM THE PEDAL, THE VIBRATION GOES AWAY. DRIVE SHAFT WAS REPLACED OVER 6 MONTHS AGO, BUT THAT DID NOT FIX THE ISSUE.*AK

DUE TO A DESIGN FLAW IN THE FORD 5.4 ENGINE MY 2002 HARLEY F-150 BLEW A SPARK PLUG LAST WEEKEND (2/15/04). FORD IS ONLY WILLING TO REPLACE THE ONE HEAD WITH THE NEWLY DESIGNED HEAD (AND THAT IS COSTING ME $500 BECAUSE MY TRUCK HAS 40,000 MILES). IT'S A KNOWN DESIGN FLAW AND HAS HAPPENED TO MANY OWERS WITH LESS THAN 10,000 MILES. FORD NEEDS TO STAND BEHIND THEIR PRODUCT.

THE VEHICLE FAILED TO ACCELERATE WHEN THE CLUTCH WAS APPLIED DURING VARIOUS SPEEDS OF 0-45 MPH. THE VEHICLE WAS TAKEN TO A DEALER WHO INFORMED THE CONSUMER THAT THE CLUTCH SLAVE CYLINDER WAS LEAKING FLUID. *JB

WHILE DRIVING CONSUMER HEARD NOISE COMING FROM THE FRONT OF THE VEHICLE WHEN ACCELERATING. *AK

LOUD HIGH PITCHED WHINE IN REAR END AT OPEN HIGHWAY SPEEDS (3.31 GEAR RATIO) DETECTED DAY OF PURCHASE ON MARCH 25TH 2002, REPORTED TO DEALER OF PURCHASE (HOMER SKELTON FORD, OLIVE BRANCH ,MS) NEXT DATE. AS OF MARCH 25TH 2003, ONE YEAR, TWO DEALERS, 29,000 MISERABLE MILES AND SOME FIVE REPAIR ATTEMPTS LATER I STILL HAVE THE SAME PROBLEM. THERE IS DEFIENTLY A PROBLEM WITH THE 3.31 FORD REAR END. I HAVE RECENTLY DRIVEN ANOTHER NEW 2003 FORD TRUCK WITH 3.31 REAR END, VEHICLE ALSO HAD NOISE. THEN DROVE ANOTHER NEW PICK UP WITH THE 3.55 REAR END WHICH WAS TOTALLY QUIET. IN THE COURSE OF THIS YEAR I HAVE FILED NUMEROUS COMPLAINTS WITH DEALERS AND DIRECTLY WITH FORD. ONE WEEK AFTER PURCHASE, WHEN THE FIRST ATTEMPT TO FIX THE TRUCK FAILED, I ATTEMPTED TOGET THE DEALER TO TAKE THE TRUCK BACK BUT THEY SAID THAT WAS NOT AN OPTION. THIS VEHICLE IS SUPPOSE TO BA A TOP OF THE LINE FORD PICKUP RETAILING FOR OVER $30,000.00 WITH A 36,000 MILE BUMPER TO BUMPER WARRANTY. FORD EITHER CAN'T OR WON'T FIX IT. THEY HAVE JUST OFFERED ME A BUY BACK ON THE TRUCK WHICH IF ACCEPTED WOULD COST ME AS FOLLOWS THE OUT OF POCKET EXPENSE AT THE TIME THE TRUCK WAS PUCHASED. $1,875.00 CASH DOWN PAYMENT 6,162.10 EQUITY OF TRADE IN 874.52 SALES TAX A TOTAL OF $8,911.62 . IN ADDITION TO THE COST OF INSTALLATION OF PERSONAL EQUIPMENT WHICH TOTALS ABOUT $400.00. THIS IS NOT EVEN CONSIDERING PAYMENTS ON THE TRUCK FOR 12 MONTHS. NOW FORD HAS OFFERED TO BUY THE TRUCK BACK IF I PAY THEM OVER $5,000.00 ADDITIIONAL DOLLARS FOR THE MILEAGE ON THE VEHICLE. THIS WOULD MAKE MY TOTAL COST OVER 13,900.00 FOR OWNING A DEFECTIVE FORD PICK UP FOR 12 MONTHS. IN ESSENCE THERE IS NO WARRANTY. IT SHOULD BE FORD'S RESPONSIBILITY TO FIX THE DEFECT IN THE VEHICLE. IF THEY COULD NOT FIX IT THEY SHOULD HAVE GIVEN ME ANOTHER TRUCK LONG AGO. IT IS THEIR FAULT THAT IT HAS TAKEN A YEAR TO GET TO THIS POINT. I TRAVEL IN MY JOB AND HAD NO CHOICE BUT TO DRIVE THE MILES ON THE TRUCK. THEY CERTAINLY WERE NOT PLEASANT ONES.

WHILE AT HIGH SPEED VEHICLE VIBRATES AND PULLS TO THE RIGHT. CONSUMER TOOK TO THE DEALER AND THEY REPLACED THE DRIVESHAFT. PROBLEM WAS STILL PRESENT. TS THE WHEELS AND TIRES WERE ALSO CHANGED BUT TO NO AVAIL. *JG

WAS DRIVING DOWN THE ROAD THE STEERING WHEEL JERKED TO THE RIGHT COULD NOT GAIN CONTROL BACK. THERE IS ONE SKID MARK 35 FEET LONG HIT AN ELECTRIC POLE WHEN CAME TO REST THE BACK PASSENGER TIRE HAD BROKE OFF AT THE AXEL. DT

WHILE DRIVING THE VEHICLE, THE TRANSMISSION BOLT CAME LOOSE AND THE FLUID WENT OUT, CAUSING PULL OUT ROAD. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION:: MR

CONSUMER STATES THERE IS A HIGH PITCH WINDING NOISE COMING FROM THE DRIVE TRAIN WHEN DRIVING OVER 65 MPH. CONSUMER FEELS THE REAR DIFFERENTRAL IS DEFECTIVE.. PLEASE PROVIDE ANY FURTHER INFORMATION.*JB

TRANSMISSION DOES NOT SHIFT DOWN, JERKS WHEN YOU ACCELERATE. *AK

WHILE DRIVING AT ANY SPEED AND WITHOUT ANY INDICATION SPEEDDOMETER AND TACHOMETER WOULD DROP DOWN TO ZERO OR STICK TO SPEED. DEALER HAS BEEN CONTACTED. HOWEVER, CAN'T LOCATE CAUSE OF PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. *AK

TRANSMISSION NOISE IN REVERSE. *AK

TRANSMISSION SLIPPING IN REVERSE, ESPECIALLY WHEN THE TRUCK HAS NOT BEEN DRIVEN WITHIN TWO DAYS. THE TRANSMISSION DOES NOT SLIP IN DRIVE ONLY IN REVERSE. *AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK