2004 Ford F-150 Visibility

I HAVE HAD 2 OF MY WINDOW REGULATORS GO OUT AND I HAVE BEEN DOING SOME RESEARCH AND FOUND OUT THAT THIS IS A COMMON PROBLEM. SOMETHING NEEDS TO BE DONE ABOUT THIS IT CAUSES A SAFETY RISK SINCE I HAVE KIDS AND WHEN THESE WINDOWS SHATTER THE GLASS GETS EVERYWHERE. I HAVE NOTICED THAT THE SAME SLIDER ON BOTH REGULATORS BROKE IN THE SAME PLACE. PLEASE DO SOMETHING ABOUT THIS BEFORE SOMEONE'S KID OR MY KIDS GET HURT. THANK YOU *TR *KB

HELLO I OWN A 2004 F150 I WAS DRIVING AND MY DRIVERS SIDE WINDOW SLID DOWN FOR NO REASON I RESEARCHED THE PROBLEM AND FOUND THAT THIS IS A COMMON PROBLEM AMONG 2004 F150 TRUCKS THE WINDOW REGULATOR HAS A PLASTIC PART THAT FAILS I WAS LUCKY THAT IT WAS A CLEAR DAY IF I HAD BEEN DRIVING IN SNOW OR OTHER HEAVY INCLEMENT WEATHER I WOULD HAVE BEEN IN TROUBLE IS THIS AGENCY INVESTIGATION THIS ISSUE? I HAVE BEEN TOLD THAT EVENTUALLY ALL FOUR OF MY WINDOWS WILL FAIL SINCERELY [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2004 FORD F150 SD. THE CONTACT STATED THAT ALL FOUR OF THE WINDOW REGULATORS FAILED, CAUSING THE WINDOWS TO BECOME LODGED INTO THE DOOR PANEL. THE DEALER WAS CONTACTED WHO ADVISED THAT THE WINDOW REGULATORS WOULD NEED REPLACING. THERE WERE NO RECALLS AND FOR THE FAILURE. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 176,123.

THIS REPORT IS FOR THE SECOND FAILED WINDOW REGULATOR FOR MY 2004 FORD F-150 FX4 DRIVER SIDE. THESE REPAIRS ARE COSTLY AND HIGHLY REPORTED. THIS IS A SAFETY HAZARD ESPECIALLY IF THIS WOULD HAVE OCCURRED WHILE THE VEHICLE WAS IN MOTION A THE TIME OF FAILURE. SURPRISING LITTLE ACTION HAS BEEN TAKEN ON THIS ISSUE... *TR

THIS IS THE SECOND REPORT I HAVE FILED WITH NHTSA FOR THE SAME COMPLAINT BUT ADDITIONAL OCCURRENCE. WHILE DRIVING ON THE HIGHWAY AT 1000 AT NIGHT AND TRAVELING 55 MPH, THERE WAS A LOUD BANG THAT SOUNDED LIKE THE TRUCK HAD BEEN SHOT, FOLLOWED IMMEDIATELY BY THE PASSENGER FRONT WINDOW DROPPING INTO THE DOOR. THE SOUND WAS SO STARTLING THAT IT ALMOST CAUSED A LOSS OF CONTROL OF THE VEHICLE. FORD KNOWS THAT THEY HAVE A DEFECT WITH THEIR WINDOW REGULATORS; HOWEVER, THEY REFUSE TO RECALL EVEN THOUGH IT IS A DEFINITE SAFETY CONCERN. THIS IS THE THIRD WINDOW I HAVE HAD FAIL IN THE EXACT MANNER ON MY 2004 F-150. A CASUAL SEARCH ON THE INTERNET CONFIRMS THAT FORD HAS HAD THOUSANDS OF COMPLAINTS FOR THIS EXACT DEFAULT AND IS REFUSING TO MAKE A REPAIR OR RECALL TO ADDRESS A KNOWN SAFETY ISSUE. NHTSA NEEDS TO TAKE ACTION ON THIS AND FORCE FORD TO DO WHAT A RESPONSIBLE AUTOMAKER SHOULD UNDERTAKE ON THEIR OWN IN ORDER TO PROTECT THE MOTORING PUBLIC. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE VEHICLE EXHIBITED A LOUD BANGING NOISE. THE CONTACT THEN NOTICED THAT THE DRIVER AND THE PASSENGER REAR WINDOWS WERE OPENED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THEY ADVISED HER THAT SHE NEEDED TO REPLACE THE WINDOW REGULATORS. THE VEHICLE WAS REPAIRED FOR THE THE DRIVER AND PASSENGER REAR REGULATORS. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. THE VIN WAS UNAVAILABLE.

WHILE DRIVING ON HIGHWAY AT 65 MPH,WITH CHILDREN IN BACK SEAT,WINDOW ON PASSENGER SIDE IN BACK FELL DOWN,ABOUT A WEEK LATER THE OTHER BACK WINDOW DID THE SAME THING .SCARED MY WIFE AND KIDS BECAUSE IT FELL SUDDENLY WITHOUT WARNING. COULD HAVE CAUSED ME TO SWERVE INTO ONCOMING VEHICLE.I REPORTED TO FORD BUT THERE ONLY RESPONSE WAS THEY SENT ME BROCHURES TO BUY A NEW TRUCK[HA HA}.I RESPONDED BY TELLING THEM THAT MY NEXT NEW TRUCK WILL BE CHEVY OR CHRYSLER. *TR

WHILE DRIVING IN TRAFFIC MY REAR PASSENGER SIDE WINDOW, FOR NO APPARENT REASON, FELL VIOLENTLY INTO THE DOOR. THIS WAS A VERY DISTRACTING INCIDENT THAT NEARLY RESULTED IN AN ACCIDENT. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE GLASS FOR THE FRONT DRIVER AND REAR WINDOWS FELL INTO THE DOOR FRAME ABNORMALLY. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AS THE WINDOW REGULATORS NEEDING REPLACEMENT. THE REGULATORS WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 20,354 AND THE CURRENT MILEAGE WAS 33,800. UPDATED 11/03/11 *BF THE CONSUMER STATED THREE OF THE FIVE POWER WINDOWS FAILED ON THE VEHICLE. THE WINDOW REGULATORS HAD TO BE REPLACED. UPDATED 03/08/12

MY 1 AND A HALF YR OLD SON AND I HAD JUST PULLED UP TO CHURCH. I ROLLED DOWN THE FRONT PASSENGER WINDOW TO TALK TO A RELATIVE AND AS I PRESSED THE DOWN BUTTON I HEARD A LOUD POP. I WASN'T SURE WHAT THE NOISE WAS, SO I WENT TO QUICKLY ROLL THE WINDOW UP AND CHECK THE OUTSIDE OF THE TRUCK. AS I TRIED TO ROLL THE WINDOW UP, I REALIZED IT WAS THE WINDOW THAT MADE THE POP BECAUSE THE WINDOW QUICKLY FELL THE REST OF THE WAY INTO THE TRUCK. AS I DID NOT HAVE ANY OTHER OPTION, MY SON AND I HAD TO DRIVE 15 MILES HOME GOING 45 MILES PER HOUR IN THE COLD FEBRUARY NIGHT (I HAD TO BUNDLE HIM UP AS BEST AS I COULD) BECAUSE THERE WAS NOT ANOTHER OPTION FOR US TO GET HOME (AND THE WINDOW WOULD NOT STAY UP). AFTER RESEARCH ONLINE (AND TALKING TO FORD DEALERS) FOUND OUT IT WAS THE WINDOW REGULATOR AND QUITE COMMON IN 2004 FORD F150 LARIATS. I FEEL THIS SHOULD DEFINITELY BE A RECALL BECAUSE IT COULD BE VERY DANGEROUS IF THIS HAPPENED ON THE HIGHWAY GOING 65 - 70 MPH! 09/27/10 (63500 MILES) - DRIVING IN TOWN THE REAR DRIVER SIDE WINDOW JUST FELL DOWN INTO THE WINDOW. NO FORD DEALER IN OUR TOWN WE HAD TO DRIVE 45 MINUTES IN THE COLD OF OCTOBER WITH A PIECE OF CARDBOARD IN THE WINDOW (THAT KEPT MOVING AND CAUSING THE WINDOW TO CONTINUOUSLY FALL INTO THE TRUCK AND HAVING TO MAKE MANY STOPS ALONG THE WAY). SAME ISSUE - WINDOW REGULATOR HAD TO BE REPLACED. 04/10/11 (69000 MILES) - DRIVING HOME FROM CHURCH IN TOWN THE WINDOW STARTED TO FALL INTO THE TRUCK. AS THIS IS THE THIRD TIME THIS HAS HAPPENED, WE ARE 100% SURE IT IS THE WINDOW REGULATOR! SETTING UP AN APPOINTMENT WITH THE FORD DEALER TO GET IT FIXED. RESEARCHED ONLINE, AND THIS HAS HAPPENED TO MANY OTHER 2004 FORD F150 LARIAT TRUCK OWNERS! AGAIN, WE ARE VERY THANKFUL WE WERE NOT DRIVING ON THE HIGHWAY AT 70 MPH WITH OUR LITTLE ONE IN THE BACK IN THE MIDDLE OF WINTER! VERY UNSAFE!

TL*THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS THE RIGHT PASSENGER SIDE WINDOW SUDDENLY FELL INSIDE THE DOOR AND HE WAS UNABLE TO CLOSE IT . THE VEHICLE WAS NOT INSPECTED BY THE DEALER NOR HAD IT BEEN REPAIRED. THIS FAILURE OCCURRED ON THE DRIVERS SIDE WINDOW ONE YEAR PRIOR AND WAS INSPECTED BY A DEALER WHO STATED THAT THE FAILURE WAS DUE TO A DEFECTIVE WINDOW REGULATOR AND NEEDED TO BE REPLACED. THE DRIVERS SIDE WINDOW REGULATOR WAS REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.

FIRST INCIDENT: AUGUST, 2009 I WAS DRIVING DOWN THE HIGHWAY GOING APPROXIMATELY 65 MILES AN HOUR WHEN THE BACK PASSENGER SIDE WINDOW STARTED DECENDING WITHOUT ANYONE PUSHING THE BUTTON. I WAS THEN UNABLE TO USE THE WINDOW AGAIN. MY INFANT SON WAS IN THE BACK SEAT NEXT TO THE WINDOW AND IT WAS RAINING. I TOOK THE VEHICLE TO THE FORD DEALERSHIP AND HAD THE WINDOW REGULATOR REPLACED. SECOND INCIDENT: JANUARY, 2010 ONCE AGAIN I WAS DRIVING AND THE FRONT PASSENGER SIDE WINDOW WENT DOWN WITHOUT PROMPTING AND NEVER WORKED AGAIN. I AM AN ATTORNEY AND WAS ON MY WAY TO THE COURTHOUSE AND WAS FORCED TO LEAVE MY CAR UNATTENDED FOR A SHORT AMOUNT OF TIME AND OBTAIN CONTINUANCES ON ALL OF MY CASES THAT DAY IN ORDER TO HAVE MY WINDOW REPAIRED. I WAS INFORMED THAT IT WAS THE WINDOW REGULATOR AND THE PART NEEDED REPLACED. THIRD INCIDENT: AUGUST, 2011 SAME SCENERIO, MY HUSBAND WAS DRIVING THE VEHICLE ON THE HIGHWAY AT APPROX. 55 MPH WHEN HIS WINDOW DECENDED WITHOUT PROMPTING AND WE WERE UNABLE TO MAKE THE WINDOW WORK AGAIN. I HAD TO HAVE THE WINDOW REGULATOR REPLACED. BESIDES THE COST OF REPAIRS ($350.00 EACH WINDOW), I BELIEVE THAT THIS IS A SAFETY HAZARD. I HAD AN INFANT BY THE WINDOW IN THE FIRST INCIDENT AND DRIVING AT SPEED THE WINDOW COULD HAVE SHATTERED. ALSO, ALL INCIDENTS OCCURED WHILE I WAS DRIVING AND PROVED QUITE DISTRACTING. IT COULD HAVE CAUSED AN ACCIDENT. LAST, BECAUSE I WAS UNABLE TO MAKE THE WINDOW(S) GO BACK UP I HAD TO LEAVE MY VEHICLE UNSECURED. *TT

2004 FORD F150 LARIAT WINDOW REGULATORS FAILING. I HAVE HAD TWO WINDOW REGULATORS FAIL WHILE DRIVING MY TRUCK WHICH CAUSES THE WINDOW TO DROP UNEXPECTEDLY INTO THE DOOR CAVITY WHICH CAUSES ALARM TO THE DRIVER POSSIBLY CONTRIBUTING TO LOSS OF CONTROL OF THE VEHICLE. FORD IS AWARE OF THIS CONDITION AND REFUSES TO CORRECT THE ISSUE. IT IS A SERIOUS SAFETY RISK. THE WINDOWS WERE NOT BEING OPERATED AT THE TIME OF FAILURE. THEY JUST DROPPED LEAVING THE WINDOW OPEN AT 75 MPH ON THE HIGHWAY. *TR

2004 FORD F150 LARIAT. RIGHT REAR WINDOW SUDDENLY DOPPED INTO THE DOOR. THW WINDOW WILL NOT GO UP. THIS IS A SAFTEY HAZARD. WHNN THE WINDOW WENT DOWN THE NOISE WAS DISTRACTING AND I HAD NO IDEA WHAT HAPPENED. I HAD TO LOOK FOR A PLACE TO STOP. AFTER STOPPING, I EXITED THE TRUCK. I THOUGHT I HAD A TIRE TREAD SEPERATION. AFTER CHECKING ALL OF THE TIRES I DECIDED TO LOOK OVER THE VEHICLE. SINCE I HAD NO IDEA WHAT HAPPENED I WAS PREPARED TO HAVE THE VEHICLE TOWED TO S SHOP. IT WAS THEN THAT I NOTICED THAT THE RR WINDOW WAS DOWN. I TRIED TO PUT IT UP AND COULD NOT DO SO WITH EITHER THE DRIVER WINDOW CONTROLL OR THE RR DOOR CONTROL. *TT

PASSINGER WINDOW FELL INTO THE DOOR WHILE DRIVING ON THE FREEWAY. *TT

WHILE DRIVING ON THE INTERSTATE THE DRIVERS SIDE WINDOW, WITHOUT WARNING, FELL DOWN INTO THE DOOR. I HEARD A POPPING SOUND AND THE WINDOW DISAPPEARED. I FEEL THIS IS A SAFETY ISSUE BECAUSE OF THE SUDDEN DISTRACTION COULD HAVE CAUSED ME TO LOOSE CONTROL OF THE VEHICLE. I LOOKED AT YOUR WEB SITE AND DISCOVERED THIS A COMMON PROBLEM WITH THIS TRUCK AND BELIEVE FORD SHOULD BE REQUIRED TO ADDRESS THE ISSUE.

THERE WAS A "POP" SOUND, FOLLOWED BY THE WINDOW CRASHING DOWN INTO THE DOOR. UPON INSPECTION THE POINT OF FAILURE IS A SMALL PULLEY ATTACHED TO THE WINDOW LIFT MOTOR. IT IS WEAKLY DESIGNED WITH HIGH TENSION FOCUSED AT 3 STRESS POINTS INSTEAD OF DISTRIBUTED ABOUT THE WHOLE PULLEY. I BELIEVE THIS IS A COMMON PROBLEM, AND CAN STARTLE A DRIVER CAUSING AN ACCIDENT, FURTHERMORE, AT HIGHWAY SPEEDS THE WINDOW COULD HAVE FALLEN INTO OR OUT OF THE TRUCK CAUSING INJURY. *TR

THE DRIVERS WINDOW FELL DOWN INTO THE DOOR WHILE TRUCK WAS MOVING. I WAS UNABLE TO GET THE WINDOW BACK UP. I WAS IN A REMOTE LOCATION, DRIVING OVER A SNOWY MOUNTAIN PASS. HE WINDOW REGULATOR FAILED, AND I UNDERSTAND THIS IS A COMMON OCCURRENCE, AND I CAN EXPECT MORE OF THE SAME IN THE FUTURE. THIS IS A POTENTIAL FOR A CRASH AS IT IS A STARTLING EVENT, AND A SERIOUS IMMEDIATE DISTRACTION. *TR

THE DRIVERS WINDOW FELL DOWN INTO THE DOOR WHILE TRUCK WAS MOVING. I WAS UNABLE TO GET THE WINDOW BACK UP. I WAS IN A REMOTE LOCATION, DRIVING OVER A SNOWY MOUNTAIN PASS. WHEN THE WINDOW REGULATOR FAILED, AND I UNDERSTAND THIS IS A COMMON OCCURRENCE, AND I CAN EXPECT MORE OF THE SAME IN THE FUTURE. THIS IS A POTENTIAL FOR A CRASH AS IT IS A STARTLING EVENT, AND A SERIOUS IMMEDIATE DISTRACTION. *TR

I HAVE HAD MY 2004 F150 XLT SUPERCREW FOR A YEAR NOW AND THE POWER WINDOW REGULATOR IN ALL 4 WINDOWS HAVE BROKEN DURING THAT SHORT PERIOD OF TIME. THE MOST RECENT FAILURE HAPPENED ON THE FRONT PASSENGER WINDOW LAST NIGHT. SEARCHING THE INTERNET SHOWS THAT THIS IS A WELL KNOWN ISSUE WITH THESE VEHICLES, BUT FORD WILL NOT ISSUE A RECALL. *TR

WINDOW FAILURE. THE LEFT REAR WINDOW JUST DROPPED OUT OF THE TRACK DUE TO A WINDOW REGULATOR FAILURE. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED WHILE DRIVING 10 MPH THE REAR DRIVER AND PASSENGER SIDE WINDOWS FELL INSIDE THE DOOR. THE REGULATOR WAS FAULTY AND CAUSED THE WINDOW TO FALL OFF TRACK. THE CONTACT DID NOT TAKE THE VEHICLE TO A MECHANIC OR DEALER FOR A DIAGNOSTIC TEST. THE CONTACT CALLED THE MANUFACTURER WHO STATED THEY WOULD DO SOME RESEARCH ON THE WINDOW REGULATOR FOR THAT YEAR, MAKE, AND MODEL VEHICLE. THE CONTACT STATED THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 90,000.

THERE ARE OVER 450 COMPLAINTS LISTED HERE IS MINE I OWN A 2004 FORD F150 AND HAVE HAD 3 WINDOW REGULATOR FAILURES, 2 WHILE DRIVING. THE DANGEROUS ONE WAS ON THE DRIVERS SIDE AT NIGHT DURING A RAIN STORM. FORD DEALER STATES HE REPLACES 1-2 A WEEK BUT IS NOT YET A RECALL. HE SAYS IT WONT GET A RECALL UNTIL SOMEONE DIES. I THINK IT IS A KNOWN DANGEROUS PROBLEM THAT FORD NEEDS TO TAKE CARE OF BUT WONT UNTIL A RECALL IS MANDATORY. PLEASE RECALL THIS PROBLEM BEFORE "SOMEONE DIES" AND "ONLY THEN" MANDATES A RECALL. THANK YOU FOR YOUR TIME. *TR

TL * THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT WHILE TRYING TO CLOSE THE POWER WINDOW, HE HEARD A POPPING NOISE AND THE WINDOW FELL INTO THE DOOR PANEL. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED ON THREE OF THE FOUR WINDOWS. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE CABLES AND THE ACTUATOR ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS OUT OF WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 85,000 AND THE CURRENT MILEAGE WAS 92,000. UPDATED 9/13/11 *CN THE VEHICLE HAS SINCE BEEN REPAIRED. UPDATED 09/30/11*JB

ON THE BELOW DATE MY PASSENGER DOOR WINDOW FELL DOWN IN TO THE DOOR. THIS IS THE 3RD WINDOW TO DO THIS. IT HAPPENED WHILE DRIVING AND SCARED ME SO BAD I ALMOST DROVE OFF THE ROAD. THERE WAS A LOUD POP AND THE WINDOW WAS GONE. *TR