2020 Ford Ranger Power Train

Purchased used in 2024 with 44,000 miles. Transmission issues began at 79,000 miles. Hard shifting, slipping and then lurching when it goes in gear. Diagnosed after transmission service ($600) as a factory defect in the 10 speed transmission. Ford has issued Service Bulletins defining and outlining the issue but has offered no assistance in rectifying and repairing. Since so many vehicles are affected there should be a recall. I understand that in Canada a class action lawsuit has been initiated.

My 10 speed 10r80 transmission is failing and dangerous. Besides slipping bucking and delaying shifting it now revs up without moving. I've almost been hit more than 6 times. My ford dealer changed the fluid road tested and normal all that I'm complaining about is normal.

I bought my 2020 Ford Ranger preowned with around 64k miles on it. After having owned it for about 6 months or so, I started to notice lots of problems with the transmission. After first noticing it, the problems persisted for a couple more months until I finally decided to address it. The problems were very characteristic of transmission slippage, and they got progressively worse week by week, which it what ultimately prompted me to address it. When accelerating and shifting through the lower gears (15-30 MPHs, approximately), the shift would be delayed and lag a couple seconds. This would often cause stalling in the acceleration, particularly when going from a stop to a start, such as through traffic lights. There were also very rough and aggressive shifts at higher gears when driving on the highway. It would feel like rough jolts that would rock the truck a little. Also transitioning the truck into reverse often caused serious jolts as the transmission shifted very aggressively. Eventually, I took my truck into an AMCO transmission shop for inspection. They confirmed that my transmission was damaged and needed replaced. This was at about 86k miles. I took the truck into a Ford dealership to get a second opinion and they also confirmed my transmission needed replaced. I went ahead and had the transmission replaced at that point. The replacement was done with the truck at 86k miles. The Ford dealership replaced the 10R80 transmission with a re-manufactured 10R80. It has now been about 8k miles and 9 months since the transmission was replaced, and the re-manufactured transmission is starting to experience similar problems. Mostly with a lag when shifting in lower gears and hard jolts when placing it in reverse. The problems are not as bad as the original transmission before I had it replaced, but some still remain. There were no warning lamps or messages with this problem. Ford's 10R80 transmission is notorious for failing and being a safety problem to the public.

When starting to accelerate, the automatic transmission shifts hart into second or third gear, and sometime has no power, like it is idling for 5 to 7 seconds before engaging. The problem has been reproduced and confirmed by Quirk Ford of Augusta, Maine who said I must have had a faulty transmission from the factory. The safety issue is hesitation from the occasional loss of power during the hard shift which could put one in danger of being rear ended. The were no warning indicators except the sudden jarring during hard shift. Other than the problem being diagnosed by the dealer, it has not been inspected. Hard shift first appeared around 75,000 miles. Dealer flushed and Changed fluid. Reappeared with loss of power during around 130,000 miles. Transmission being replaced 12/15/25 at $9200. Ford basically said it was my problem. I have had two ford rangers before that I drove for over 230;000 miles each without any transmission issues. Clearly the 10 speed transmission is flawed and needs a recall.

all of these issues: Shuddering at the point of acceleration Inability to reach desired speed Gear lockout Failure to start Shifter “lockout” or being “stuck in park” Hesitation from a stopped position Sluggish performance, including during towing “Check engine” light “Juddering,” which involves shaking of the vehicle during normal operation Loss of power or failure to engage

On the freeway cruise control at 75 mph, truck started down shifting in to 7th gear, then back up and continued to do this several times until i reached my destination. Took it out of cruise control and still did it. It did it again about 3 days later. I took it to ford dealership, they test drove it and it wouldn't do it for them.

My transmission start to skip about two years ago, l took to Ford Dealership, they check the code, everything was good, we check the 3 months ago, everything okay, but it still kept skipping, so l change the fluid, and filter, still skips, for wanted over $600.00 to see what the problem, said l had no warranty, I’m a 71 year old disabled Senior on a fixed income, , didn’t have the money, l don’t know what to do

Automatic transmission Available for request Accelerating and stoping proves to be a safety issue on the roadways Confirmed by anyone that drives the vehicle Not inspected, out of warranty and can not afford replacement No lamps

Internal component failure of the 10R80 transmission. While driving one evening on a highway the vehicle while in cruise began bucking, surging and reduced gears. The vehicle began spraying transmission fluid on vehicles behind me and what was once a 10 speed transmission became a 7 speed transmission. Prior to failure there was zero indication of an issue. Nearly getting into an accident I had to make my way to the side of the road where there wasn’t much of a flat shoulder. Not only could my sudden decline in speed have caused an accident but the transmission fluid spraying on vehicles behind me could have reduced others visibility. Dealership near the incident area has confirmed internal failure which is extremely common for these transmissions. Vehicle is currently awaiting a replacement transmission.

Rough shift and jerkings around 35 to 40 mph

When accelerating from a stop, there is a lag in the engine shifting into gear, it causes the RPM's to climb before eventually shifting gears and once it does that the whole vehicle jolts forwards. There is also a noticeable lag when the vehicle is shifting from 1st and second, as well as a jolt when it does shift but not as much of a jolt as the initial 1st to 2nd. Once the vehicle is up to 3/4th gear, it does not appear to have the same issue shifting. This poses a safety issue in numerous situations. One example being, when stopped at an intersection and trying to make a left hand turn, I have to be extremely cautious that I have plenty of space as to account for the potential lag and not being able to accelerate quickly.

Repeated problems with the 10 SPD automatic transmission in my 2020 Ford Ranger. Transmission skips between gears, shakes, jerks, feels like I’m driving over rumble strips. You name it, the transmission is doing it. Took it to the Ford dealership last year and they “cannot reproduce the issue”. That’s because it doesn’t happen all the time. I guess I need to take a technician on a road trip with me to identify the issue. Fast forward to now…warranty is gone and problem still persists. Only 28,000 on the truck. Waiting on a recall to replace the transmission. I mean, these issues are all over the internet. Super common issue. The transmissions are obviously faulty and Ford refuses to resolve the issue. I am beyond irritated at this point

Transmission issues since purchasing used. Has been in once for Transmission reprogramming. Less than 6 months later, Transmission now bucks when foot removed from accelerator and shifts out of gear while driving. Returning to Lincoln dealer 6/6 for additional service.

The contact owns a 2020 Ford Ranger. The contact stated that while the vehicle was in reverse(R), the vehicle jerked before the transmission responded as needed. The contact stated that the vehicle returned to normal functionality afterwards. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed that the gear shifter assembly needed to be replaced. The vehicle was not repaired. The contact stated that on a separate occasion, while driving 50 MPH, there was an abnormal humming sound coming from the vehicle before the transmission unexpectedly downshifted. The contact stated that unknown warning lights were intermittently illuminated. The vehicle was taken to a dealer and was diagnosed with an internal leak in the transmission which caused the failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired after the latest failure. The manufacturer was contacted and opened a case. The contact related the failure to Ford Campaign Number: 242046. The failure mileage was approximately 77,000.

My 2020 Ford Ranger, which I bought new on [XXX] from Stivers Ford in Montgomery, AL, has a 10 speed 10R80 transmission which has adaptive learning. It has put myself and others' safety at risk because it shifts gears erratically and sometimes hesitates when pulling out into traffic even though the gas peddle is pressed. I first reported these transmission issues to the Stivers Ford dealership on 11/09/20 when the truck had only 5,275 miles. They said that the transmission "operates as designed" verbally and printed the same on the service invoice. I reported the issue multiple times to Stivers Ford thereafter each time I had the oil changed and they repeated verbally that the transmission "operates as designed". The problem persisted and progressively got worse and began to create scary conditions by hesitating when pulling out into and in front of moving traffic, until finally 8/27/24 with 89,407 miles I insisted to Stivers Ford Dealership that they fix it. They agreed to look at problem again, and, when I picked it up, they said they reset the adaptive learning to the factory specs, which fixed the problem perfectly, until April of 2025, when the problem reappeared. The Stivers dealership refused to look at it again as a warranty issue, even though I reported the problem when it was under warranty and they told me to contact Ford Manufacturing. The Ford MFG representative on 05/29/25 said they would not help and suggested I contact the NHTSA. I currently have my truck at a different dealership and told them I would pay for the temporary fix of resetting the adaptive learning. PROBLEM: Ford MFG has allowed me AND the general public to purchase their new vehicle with a defective and unsafe 10R80 transmission and I'm in hopes your department will require them to recall this transmission and replace or fix it. I appreciate you reading all this and hope you will respond to me in some way. My number is [XXX] if you need any additional information. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal knocking sound. The vehicle was taken to a dealer and was diagnosed with transmission failure. The vehicle was repaired but the sound persisted. The vehicle was taken to the dealer again and diagnosed with transmission failure again. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

The contact owns a 2020 Ford Ranger. The contact stated that while driving at undisclosed speeds, there was an abnormal squeaking and humming sound coming from the vehicle. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who determined that the failure was due to the carrier bearings and there was no grease or scratches. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 64,000.

The contact owns a 2020 Ford Ranger. The contact stated that on several occasions while driving between 40-45 MPH, the vehicle began jerking and the transmission was skipping. Additionally, the vehicle lost power and was consuming an excessive amount of fuel. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 55,900.

The Transmission in this truck has problems the 10 speed shifts hard on down shifts and slips on up shifts. This should have a recall to be addressed

Problem shifting,jerky motion or no response at all with the transmission had to pull over almost was rear ended because of no response.

At about 40,000 miles truck started jumping and hesitating under 30mph and has now gotten worse and jumping and hesitating at 65mph had it in the shop 3 times and they can't find the problem they came up with driveshaft and pinion flange. It came from Detroit and I believe it is a problem with the transmission.

Transmission has difficulty moving through gears- powertrain failure noted via alert system x2 when vehicle stopped abruptly while driving. "Powertrain Malfunction/Reduced Power". Fortunately no one injured. 60k miles on the vehicle and Ford reporting need a 6k new transmission.

Transmission has rough and erratic shifts at lower speeds. Bucking and bouncing of the vehicle occurs do to the shifting.

The contact owns a 2020 Ford Ranger. The contact stated while attempting to accelerate from a complete stop, the vehicle failed to respond. The contact shifted into neutral(N), and then shifted back into drive(D). The contact stated that the vehicle responded, then jerked forward and backward. The contact stated that the failure recurred several times while driving from a complete stop; however, on the latest failure, the vehicle failed to respond and stalled. The vehicle was pushed to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 109,000.

The 10 speed automatic transmission has a problem. Yes the problem was verified by the Dealer. Yes the Dealer has had the car 3 separate times and worked on the issue. The transmission when starting out from a stop will fall on its face with no power to move from the stop. 2-4 seconds and then it takes off. When pulling out into traffic this condition is very unsafe and could cause an accident. Now it is starting to do it as traveling at speed and light acceleration it will hesitate before it goes. This is an intermittent problem not doing it all the time .