2008 Toyota Highlander Engine

ENGINE OIL COOLING (RUBBER) HOSE BURST WHILE DRIVING AND DUMPED ALL OF MY OIL ... TOYOTA HAS SINCE REPAIRED THIS PART WITH A SERIES OF METAL PIPES, WHICH SUGGESTS TO ME THAT THEY REALIZE THAT THIS IS A DEFECT BUT IT IS NOT ACKNOWLEDGED AS A RECALL

I RECENTLY NOTICED A RATTLING SOUND OUT OF THE ENGINE AREA THAT OCCURS INTERMITTENTLY. IT TYPICALLY OCCURS AFTER THE VEHICLE SITS FOR A COUPLE HOURS AFTER IT HAS BEEN DRIVEN UP TO OPERATING TEMPERATURE. THE SOUND HAPPENS FOR LESS THAN 2 SECONDS. THE TOYOTA DEALER IN OUR AREA DIAGNOSED THE ISSUE AS A FAILURE OF THE INTAKE CAM GEAR PER TOYOTA TECHNICAL SERVICE BULLETIN 0094-09. THE SERVICE ADVISOR STATED THAT IF THE ISSUE IS LEFT UNADDRESSED, IT COULD LEAD TO COMPLETE ENGINE FAILURE. HE ALSO STATED THAT THE UPDATED CAM GEAR MADE BY TOYOTA DOES NOT FIT THE EXISTING CAMSHAFT. THIS MEANS THAT ALL 4 CAM GEARS AND TWO CAMSHAFTS WOULD HAVE TO BE REPLACED WHICH DRAMATICALLY INCREASES THE LABOR AND PARTS COSTS. I WAS GIVEN THE FOLLOWING QUOTE FOR THE REPAIR: PART'S $3748.00 LABOR $2137.00 TAX $348.00 TOTAL $6233.00 I TOOK THE VEHICLE TO ANOTHER TOYOTA TO CONFIRM THE DIAGNOSIS AND THEY CONFIRMED THE ISSUE AND QUOTED ME AT A SIMILAR PRICE TO DO THE REPAIR. MESSAGE BOARDS ALL ACROSS THE INTERNET DESCRIBE A SIMILAR PHENOMENON. AFTER DISCUSSING THE MATTER WITH TOYOTA CORPORATE, THEY AGREED TO COVER 50% OF THE PARTS COST, BUT I BELIEVE THIS TO BE UNFAIR BECAUSE THEIR UPDATED PART INTRINSICALLY AND DRAMATICALLY INCREASES THE LABOR AND PARTS COSTS. EVEN THOUGH ONLY ONE CAM GEAR FAILED, THE REPLACEMENT OF ALL 4 CAM GEARS IS NOW NECESSARY.

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE AIR CONDITION TUBE FAILED WHILE DRIVING. THE CONTACT INSPECTED THE VEHICLE AND DISCOVERED THAT THE AIR CONDITION TUBE WAS EXPOSED TO THE MOTOR VENTILATOR CAUSING THE TUBE TO OVERHEAT AND EXPLODE, SPILLING THE COOLANT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE DRIVING 50 MPH, THE CONTACT SMELLED BURNING OIL. THE CONTACT PULLED OVER AND FOUND A LEAK IN THE MOTOR OIL COOLING HOSE. THE VEHICLE WAS TOWED TO A DEALER TO BE REPAIRED. IN ADDITION, THE MECHANIC FOUND AN ISSUE WITH THE CAM SHAFT OF THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 126,000.

I PURCHASED A QUALIFIED PRE-OWNED 2008 TOYOTA HIGHLANDER SPORT FROM RICE TOYOTA IN GREENSBORO, NC IN FEBRUARY OF 2013. SINCE THAT TIME, I HAVE PROPERLY SERVICED THE VEHICLE AND RETAINED ALL SERVICE RECORDS. ON OR ABOUT MARCH 31, 2015, WHILE I WAS DRIVING HOME FROM WORK ON I-40 (65 MPH INTERSTATE HIGHWAY), THE ENGINE IN MY HIGHLANDER SUDDENLY STALLED AND THE CHECK ENGINE LIGHT CAME ON. I COASTED INTO A REST AREA (LUCKILY) AND WAS TOWED TO A SERVICE STATION IN GREENSBORO. A COMPLETE DIAGNOSTIC WAS PERFORMED AND IT WAS DETERMINED THAT THE ENGINE FAILURE WAS DUE TO A FAULTY ENGINE VALVE SPRING. EVERY MECHANIC I HAVE SPOKEN WITH HAVE INDICATED THAT A VALVE SPRING SHOULD NOT BREAK ON A 2008 TOYOTA WITH AROUND 100K MILES. I SEARCHED ONLINE AND FOUND THAT TOYOTA HAS RECALLED HUNDREDS OF THOUSANDS OF CERTAIN LEXUS MODELS, INCLUDING MODELS FROM 2008 WITH THE SAME 3.5 LITER V6 ENGINE AS IS IN MY HIGHLANDER, FOR FAULTY VALVE SPRINGS THAT RESULT IN SUDDEN ENGINE STALLING. RICE TOYOTA HAS REFUSED TO PROVIDE ANY ASSISTANCE, AS HAS TOYOTA CORPORATION. FURTHER, TOYOTA CORPORATION HAS REFUSED TO PROVIDE ME WITH ANY INFORMATION REGARDING THE MANUFACTURER OF THE VALVE SPRING IN MY VEHICLE AND/OR ANY INDICATION IF THE SAME VALVE SPRING WAS IN THE RECALLED LEXUS MODES. I HAVE SEEN CLASS ACTION LAW SUITS FILED AGAINST TOYOTA FOR CONCEALING ISSUES WITH VALVE SPRINGS. THIS DEFECT CAN BE VERY DANGEROUS AS THE VEHICLE STALLS SUDDENLY AND WITHOUT WARNING. I NEED ASSISTANCE TO MOTIVATE TOYOTA CORPORATION AND RICE TOYOTA TO CORRECT A CLEAR DESIGN AND/OR MANUFACTURING DEFECT THAT CAUSED A POTENTIALLY DANGEROUS ENGINE STALL IN THE MIDDLE OF A MAJOR INTERSTATE HIGHWAY. *TR

ACCORDING TO THE FOLLOWING WEBSITE, THERE IS A KNOWN ISSUE WITH A CHEAP PART ON THE TOYOTA V6 ENGINES. THERE WAS EVEN A RECALL FOR THE PART, HOWEVER, I"M TOLD MY CAR WASN'T ON THE RECAL LIST. HTTPS://SITES.GOOGLE.COM/SITE/TOYOTAV6OILLINESCANDAL/ THE ISSUE AT HAND IS THE CAR HAS BEEN TO THE DEALER FOR ALL MAINTENANCE, SO ITS NOT A NEGLECT ISSUE. THE REAR BANK VVT-I OIL LINE USED IN PRIOR TO 2008 (MINE HAS THIS ISSUE AS WELL) IS METAL WITH A RUBBER HOST CONNECTING THE TWO. THE HOSE RUPTURES, DUMPS ALL OF THE OIL, WHICH SQUIRTS ONTO THE PASSENGER WHEEL, IN THE BRAKES, ETC. IT CAN NOT ONLY CAUSE A FIRE IN THE ENGINE BAY (WHICH IT DID NOT IN THIS CASE), BUT IT COULD ALSO LEAD TO AN INABILITY TO STEER OR BRAKE (NEITHER WERE THE CASE HERE). LASTLY, 6 QUARTS OF OIL DRAINED OUT IN LESS THAN 60 SECONDS, AND THE ENGINE COULD HAVE SEIZED. THIS IS A SERIOUR ISSUE FOR A $35.00 PART.

THE OIL LINE HAS DEGRADED, CAUSING TOTAL LOSS OF ENGINE OIL AND POSSIBLE ENGINE DAMAGE. *TR

ENGINE OIL LEAKED ALMOST EMPTY. WHEN I PICKED UP KID FROM SCHOOL PARKING ON THE DRIVEWAY ON THAT RAINY DAY, SAW A LEAK LINE ON THE WET GROUND. NEXT SATURDAY I FILLED A QT OIL TO THE LEVEL AND DROVE TO REPAIR SHOP. THE TECHNICIAN SAID ALMOST ALL 5.5 QT OIL WAS LEAKED OUT. TURNED OUT IT WAS TIMING CHAIN COVERS SILICON SEALER BROKEN. I AM THE PERSON ALWAYS CHECK AROUND MY CAR BEFORE GOING OUT, IF NOT CHECKING, THINGS COULD BE VERY BAD. *TR

AFTER PARKING THE CAR AT THE AIRPORT FOR A COUPLE OF DAYS AND UPON RETURN STARTED THE CAR AND STARTED HEARING GRINDING NOISE FROM THE PASSENGER SIDE OF THE ENGINE AND WOULD NOT BE AUDIBLE AT THE HIGHWAY OR FREEWAY DRIVING SPEEDS (> 40 MILES). TOOK TO THE DEALER TO GET 2 OUTSTANDING RECALLS (SPIRAL CABLE AND SOFTWARE UPDATE FOR BRAKE PEDAL OVERRIDE) AND WAS TOLD THAT THE WATER PUMP IS FAILING. COST COULD BE AROUND $800 AND WAS NOT HAPPY TO HEAR AS THE QUALITY OF THESE PARTS CONSISTENTLY BEEN DETERIORATING AND HAD TO REPLACE ON EARLIER TOYOTA'S THAT I OWNED. *TR

I WAS DRIVING HOME FROM WORK. THE OIL COOLER HOSE FAILED LEAKING OIL AND SMOKING FROM BURNING ON EXHAUST THEN OIL PRESSURE LIGHT CAME ON. DEALER SAYS RECALL WAS DONE ALREADY HOWEVER IT APPARENTLY DID NOT FIX THE ISSUE. THEY SAY THEY CAN'T DO ANYTHING CAUSE IT WAS ALREADY DONE ONCE. NOT SURE IF ANY ENGINE DAMAGE WAS DONE NEED TO HAVE IT TOWED TO A SHOP. *TR

THE OIL COOLER HOSE ON MY 2008 HIGHLANDER SUDDENLY MALFUNCTIONED, CAUSING MOST OF MY CAR'S OIL TO SPILL OUT ON TO THE DRIVEWAY. APPARENTLY, THIS PARTICULAR RUBBER HOSE HAS BEEN THE SUBJECT OF RECALLS AND EQUIPMENT UPGRADES TO A METAL PIPE IN OTHER TOYOTA MODELS, BUT NOT THE HIGHLANDER. THIS IS A SAFETY ISSUE THAT TOYOTA IS NEGLECTING TO ACKNOWLEDGE IN ITS HIGHLANDERS. I CALLED MY LOCAL TOYOTA DEALERSHIP TO REPORT THE PROBLEM, AND ASK WHAT TOYOTA IS DOING TO FIX IT, AND THEY DENIED THERE WAS ANY KIND OF PROBLEM WITH THE OIL COOLER HOSES. A SIMPLE GOOGLE SEARCH IMPLIES OTHERWISE. *TR

OIL PRESSURE WARNING LIGHT WENT ON ALMOST IMMEDIATELY PULLED OVER FOUND NO OIL ON DIPSTICK HAD RAPID OIL LEAK, DEALER REPLACED OIL COOLER HOSE WITH OIL COOLER PIPE. *TR

I NORMALLY RIDE A VANPOOL, BUT DUE TO FLASH FLOOD WARNINGS TODAY I DECIDED TO DRIVE MY CAR INTO THE OFFICE. MY HUSBAND CALLED ME AT WORK TO TELL ME HE NOTICED A BIG OIL SPOT ON THE GARAGE AFTER I LEFT FOR WORK. HE TOLD ME TO PULL OVER AND NOT DRIVE MY HIGHLANDER IF IT STARTED CLACKING OR SMOKING ON MY WAY HOME. MY HUSBAND JUST CHANGED THE OIL IN MY CAR A FEW DAYS PRIOR. BEFORE I COULD MAKE IT HOME THE CAR WAS SMOKING, KNOCKING, AND SHIFTING VERY LOUDLY. MY HUSBAND SAID I WAS LUCKY THIS DIDN'T LOCK UP THE ENGINE. HE DISCOVERED OIL SPLATTERS ALL OVER THE TIRE AND NEAR THE ENGINE. WE HAD NO ISSUES AT ALL PRIOR TO TODAY. WE ARE GOING TO TRY REPLACING THE OIL LINE AS DENOTED IN OTHER PEOPLES COMMENTS. THEIR EXPERIENCES WITH THIS ISSUE MIRROR MY EXPERIENCE. I'M DISAPPOINTED TO HEAR TOYOTA ISSUED A SERVICE BULLETIN ABOUT THIS AND NOT A SAFETY RECALL. THIS COULD HAVE BEEN A HUGE SAFETY ISSUE AS I'M HAULING KIDS TO/FROM DAYCARE DURING RUSH HOUR TRAFFIC NOT TO MENTION LOCKING UP THE ENGINE. THIS CAME OUT OF THE MIDDLE OF NOWHERE. *TR

TOYOTA'S T-SB-0201-1 SHOULD TRIGGER A RECALL!! MY WIFE WAS DRIVING HER '08 HIGHLANDER, WITH 2 CO-WORKER PASSENGERS, TO A FUNERAL. ON 95N IN DANVERS, MA, A MOTOR BIKER PULLED ALONGSIDE & FLAGGED MY WIFE TO PULL OVER ASAP AS THERE WAS SMOKE COMING FROM THE ENGINE COMPARTMENT AND UNDER THE CAR. AFTER STOPPING THE CAR & WAITING FOR THE SMOKE TO DISSIPATE,HE CHECKED & FOUND THERE WAS NO LONGER ANY OIL IN THE ENGINE, THE OIL HAD EMPTIED FROM THE ENGINE THE LAST FEW MILES WHILE ON THE HIGHWAY. I ARRIVED LATER THAT MORNING TO INVESTIGATE, TO DISCOVER THAT THE OIL WAS BELOW THE DIPSTICK. THE BOTTOM OF THE ENGINE & ENTIRE UNDERSIDE OF THE VEHICLE, INCLUDING THE EXHAUST SYSTEM, SPARE TIRE, WHEEL WELLS, RIGHT WHEELS & TIRES & REAR LIFTGATE WERE COATED IN ENGINE OIL. THE SMOKE APPARENTLY WAS FROM OIL SPLASHING ONTO THE HOT EXHAUST SYSTEM, & VAPORIZING DUE TO THE HIGH TEMP, CREATING A POTENTIAL FIRE HAZARD. WE HAD THE CAR TOWED TO THE NEAREST TOYOTA DEALERSHIP. THEY DETERMINED THAT AN OIL COOLER LINE EXTERNAL TO THE ENGINE - PART OF A TOWING OPTION PACKAGE THE CAR HAS - HAD RUPTURED! THE ENGINE'S OIL HAD BEEN PUMPED OUT BY THE OIL PUMP. WE HAVE SINCE DISCOVERED THAT TOYOTA HAD ISSUED A TECHNICAL SERVICE BULLETIN - T-SB-0201-11 - IN DECEMBER 2011 WHICH ADDRESSED "OIL SEEPAGE" FROM THIS EXACT OIL LINE. NOW WE ARE $480 POORER, & WE COULD HAVE EXPERIENCED A $10 K ENGINE FAILURE DUE TO SEIZING, & POSSIBLE INJURY OR LOSS OF LIFE DUE TO THIS. THIS TSB WAS NEVER PERFORMED ON OUR CAR AS WE HAD NEVER SEEN SPOTTING IN OUR DRIVEWAY FROM THIS LEAK. THE NEW PART INSTALLED WAS REDESIGNED AS SOLID METAL TUBING TO FIX THE ORIGINAL RUBBER HOSE WITH CLAMPS. INSTEAD OF RECALLING ALL OF THE AFFECTED VEHICLES TO REPLACE THIS POTENTIAL LIFE TAKER, TOYOTA SIMPLY SWEPT IT UNDER THE RUG AND ONLY REPLACED THEM WHEN SOMEONE SAW A LEAK AND ONLY WHEN THEY STILL WERE BELOW THEIR 36,000 MILEAGE WARRANTY. CRAZY! *TR

DRIVING IN PARKING LOT AT APPROXIMATELY 5MPH WHEN SMELLED BURNING OIL. PARKED CAR AND NOTICED SMOKE FROM UNDER THE HOOD. TURNED OFF CAR AND CHECKED UNDER THE HOOD AND NOTICED OIL OVER ENGINE. SEARCHED ONLINE AND SAW ISSUE WITH OIL-COOLER LINE "TOYOTA: ON SOME VEHICLES, THE ENGINE OIL COOLER PIPES MAY EXHIBIT AN OIL SEEPAGE. INFORMATION HAS BEEN PROVIDED REGARDING THIS ISSUE". THIS DID TURN OUT TO BE THE ISSUE. FORTUNATELY THIS EVEN OCCURRED WHEN WE WERE IN A PARKING LOT AND NOT DRIVING DOWN THE HIGHWAY WITH KIDS IN THE BACK. THIS IS A SIGNIFICANT ISSUE THAT COULD RESULT IN A FIRE AND/OR ENGINE DAMAGE. THE DEALER STATED THEY WERE AWARE OF THIS SERVICE NOTICE BUT NO OFFICIAL RECALL HAD OCCURRED. THIS HAS THE POTENTIAL TO BE A SIGNIFICANT ISSUE TO BOTH THE CARS AND PASSENGERS AND I HOPE THAT A RECALL WOULD OCCUR. *TR

HIGH PRESSURE OIL COOLER LINE FAILURE OF RUBBER HOSE SECTION DUMPED 5 QTS OF ENGINE OIL SOAKING UNDERCARRIAGE AND SPRAYING ONTO NEARBY HOT EXHAUST PIPE AND RIGHT REAR TIRE. NO INDICATION OF LOSS OF OIL PRESSURE ON VEHICLE MONITORING SYSTEM. NOTICED A FAINT SMELL OF BURNT OIL WHEN VEHICLE WAS PARKED. RETURNED LATER TO START VEHICLE AND HEARD AUDIBLE ENGINE NOISE AND TURNED OF ENGINE TO INVESTIGATE UNDER HOOD, A NOTICEABLE PUDDLE OF OIL HAD ACCUMULATED UNDER CAR. VEHICLE TOWED FOR DIAGNOSES AND REPAIR. *TR

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, SHE BEGAN TO HER A KNOCKING NOISE IN THE ENGINE. THE CONTACT PARKED THE VEHICLE AND HAD IT TOWED TO A CERTIFIED MECHANIC WHICH STATED THAT THE ENGINE COOLER HOSE HAD A HOLE AND CAUSE THE ENGINE OIL TO LEAK OUT OF THE VEHICLE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT WAS DRIVING 55 MPH WHEN THE VEHICLE BEGAN TO EMIT A BURNING OIL SMELL. THE CHECK ENGINE LAMP ILLUMINATED SO THE CONTACT ADDED OIL TO THE VEHICLE. THE CONTACT STATED THAT THE BURNING OIL SMELL STILL LINGERED AND THE CHECK ENGINE WARNING LAMP ILLUMINATED AGAIN. IN ADDITION, A HOSE FROM THE ENGINE FAILED AND SPILLED MOTOR OIL ON THE EXTERIOR OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION WHERE THE CONTACT WAS INFORMED THAT THE OIL COOLER LINE HAD EXPLODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

2008 TOYOTA HIGHLANDER WAS TAKEN TO TOYOTA DEALER IN NOVEMBER 2011 AFTER RECEIVING NOTICE TO HAVE DEFECTIVE OIL COOLER HOSE CHECKED. IN SEPTEMBER 2013 REPLACEMENT OIL COOLER HOSE FAILED WHILE ON HIGHWAY TRAVELING AT SEVENTY MILES PER HOUR. OIL WAS OBSERVED COVERING BOTTOM OF VEHICLE AND FILM OF OIL ON BACK OF VEHICLE. THE OIL GAUGE INDICATED NO OIL IN ENGINE. I BELIEVE THIS RESULTED IN A SAFETY HAZARD FROM BOTH INHALING FUMES AND POTENTIAL FIRE HAZARD. VEHICLE WAS TOWED TO TOYOTA DEALER AND OIL COOLER HOSE REPLACED FOR SECOND TIME IN LESS THAN TWO YEARS. *TR

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND TAKEN TO THE DEALER FOR INSPECTION. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

I JUST BECAME AWARD OF THIS: "T-SB-0201-11 FROM TOYOTA THAT STATES "SOME VEHICLES EQUIPPED WITH 2GR-FE/FXE TOWING PACKAGE ENGINES MAY EXHIBIT AN OIL SEEP FROM THE ENGINE OIL COOLER PIPES." *TR THIS TSB AFFECTS MY MODEL YEAR AND I BELIEVE IT ALSO AFFECTS TOYOTA AND LEXUS VEHICLES GOING BACK TO AT LEAST 2008-PRESENT. TO ME THIS IS A MAJOR SAFETY ISSUE AND THIS SHOULD BE HANDLED AS A RECALL INSTEAD OF A TSB DUE TO THE SEVERITY OF THE ISSUE IF/WHEN THE PIPE BREAKS. THE RUPTURE OF THE OIL LINE WILL CAUSE THE ENGINE TO SEIZE THUS INCREASING THE RISK OF A CRASH WITH RESULTING INJURY AND POSSIBLE DEATH. AND THERE IS THE HAZARD TO OTHER MOTORISTS WITH OIL ON THE ROADWAY. COMPARED TO THE RECALL FOR FLOOR MATS AND ACCELERATOR ISSUES, THIS ISSUE, WHICH CAN DRAIN THE OIL FROM YOUR ENGINE VERY QUICKLY, DESTROY THE ENGINE, AND VERY POSSIBLY CAUSE AN ACCIDENT SHOULD BE OF MAJOR CONCERN TO ALL. THE TOYOTA ADVICE TO CHECK FOR SLOW OIL DRIPS AROUND THE RUBBER HOSE IS UNREALISTIC FOR THE OWNER DUE TO THE LOCATION. AND THE SCHEDULE ROUTINE SERVICE INTERVAL IS MUCH TOO LONG TO WAIT FOR SUCH AN SIGNIFICANT INSPECTION. NHTSA NEEDS TO COMPEL TOYOTA TO REPLACE ALL OF THE DEFECTIVE RUBBER ENGINE OIL COOLER PIPES WITH THE NEWER METAL ONES THAT THE TSB ADDRESSES. THIS DIRECTIVE SHOULD APPLY TO ALL TOYOTAS INCLUDING ALREADY MADE REPLACEMENTS FOR WHICH THE OWNERS HAVE PAID FOR.

LOW OIL NOTICE CAME ON. DRIVE 1/4 MILE TO OIL CHANGE FACILITY. WAS TOLD ALMOST NO OIL ON DIPSTICK. OIL REFILLED AND DROVE APPRO 5 MILES TO DEALERSHIP- STAR TOYOTA , LEAGUE CITY, TX. HAVE RESEARCHED AND NOTED TSB ISSUED ON 3/11/2011- NHTSA REFERENCE # 10033553 WITH THIS EXACT REPAIR PROBLEM INCLUSIVE OF MY VEHICLES EXACT FAILURE WAS NOT NOTIFIED BY STAR TOYOTA DEALERSHIP OF THIS DEFECT WHILE UNDER WARRANTY. VEHICLE WITHIN 5-6 MONTHS OF BASIC WARRANTY; 5 YEAR OF 60,000 MILES. *TR

THE VVT-I OIL COOLER HOSE BURST RESULTING IN A MAJOR ENGINE OIL SPILL IN A RESIDENTIAL DRIVEWAY. THE TOYOTA DEALERSHIP AND TOYOTA CORPORATE HEADQUARTERS REFUSE TO ASSUME RESPONSIBILITY FOR THE DEFECTIVE PART BECAUSE THE VEHICLE IS OUTSIDE THE WARRANTY PERIOD AND BECAUSE THEY CLAIM THERE IS NO RECALL FOR THIS PART ON THE HIGHLANDER. THIS SAME VVT-I OIL COOLER HOSE HAS BEEN RECALLED ON 1.6 MILLION US RAV4'S, CAMRY'S AND OTHER TOYOTA MODELS. NOT ONLY COULD A TOTAL LOSS OF ENGINE OIL CAUSE CATASTROPHIC ENGINE FAILURE, THIS ISSUE CAN ALSO BE CONSIDERED A SAFETY CONCERN. IF ENGINE OIL WERE TO HAVE MADE CONTACT WITH HOT ENGINE PARTS OR HOT EXHAUST PIPING, THEN A FIRE MAY HAVE OCCURRED WHICH COULD HAVE RESULTED IN SERIOUS VEHICULAR DAMAGE AND LOSS OF LIFE. *TR

OIL LEAK FROM BACKSIDE OF ENGINE. TOYOTA HAS ACKNOWLEDGE THE ISSUE WITH A SERVICE BULLETIN TSB-0321-08 BUT DID NOT PERFORM A RECALL. THEREFORE, YOU MAY EXPERIENCE THIS PROBLEM AND YOU MAY FIND THE ISSUE AFTER YOUR WARRANTY EXPIRED. THIS IS A VERY EXPENSIVE REPAIR - ESTIMATED TO BE MORE THAN $2K. TOYOTA CONTINUE TO EXPERIENCE QUALITY PROBLEMS AND SHOULD HONOR THEIR PRODUCTS WITHIN OR OUTSIDE THEIR WARRANTY WHEN IT IS CLEARLY RELATED TO POOR QUALITY. *TR

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, HE NOTICED A LARGE AMOUNT OF OIL IN THE DRIVEWAY. THE CONTACT CHECKED THE OIL LEVEL AND IT SHOWED THAT THERE WAS NO OIL IN THE VEHICLE. HE THEN ADDED OIL AND FOUND A STEADY STREAM LEAK FROM A RUBBER HOSE. THE CONTACT PURCHASED AN AFTER MARKET METAL HOSE AND REPLACED THE DEFECTIVE HOSE. HE THEN DRAINED THE OIL AND FOUND THAT THERE WERE METAL SHAVINGS IN THE OIL, WHICH HE ASSUMED CAME FROM THE BEARINGS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 64,000.