2019 Toyota RAV4 Structure

The hinge has broken from the body, causing the liftgate to fail to close the back trunk area of the vehicle. The defective hinge has caused misalignment of the door and an unsecure compartment which is a violation of NC State Law according to NC GS 20-116. This puts the passenger's and driver of the vehicle and other surrounding vehicles at risk by failing to stay aligned or seal properly. I fear that glass may crack due to the currently misalignment. I have sought out further information from a Vehicle Repair Center, who confirmed there is a current Lawsuit on the Case No.: 5:24-cv-00912ZACH HUGHES, individually and on behalf of all others similarly situated, Plaintiffs, v. TOYOTA MOTOR SALES, U.S.A., INC., TOYOTA MOTOR CORPORATION, and TOYOTA MOTOR.

The rear trunk door would occasionally fail to open or shut for the last several years. It was inconsistent with this behavior and I was never able to get it to fail when at the dealership servicing department. This weekend when at the store, it failed shutting and I had to force it to shut. While driving home it rattled itself open. I had to pull over to inspect it and could not get it to close. When I looked closer, the hinge of the door had been ripped from the body on the passenger side of the vehicle. I have never been in an accident nor have I ever had any impact on this door.

I began experiencing intermittent rear liftgate sensor issues on my 2019 Toyota RAV4 in late 2020. The power hatch would stop halfway while opening. On 3/24/2021, while the vehicle was under factory warranty, I brought it to a Toyota dealer for inspection. The dealer stated the issue could not be replicated and advised me to manually push the hatch upward. No repair was made. Over time, the condition worsened. The liftgate began intermittently stopping halfway while closing, using both the key fob and the interior dash button. In 2022, a rattling noise developed in the rear of the vehicle, later determined to be associated with progressive liftgate structural failure. By 2024, the rear liftgate became unsafe and largely inoperable. The hatch shifted significantly to the left, leaving an abnormally large gap at the top and driver’s side. I stopped using the liftgate due to concern it could fail unexpectedly or not close properly. I contacted Toyota Engagement Services multiple times, explaining that this issue is widely reported among 2019 RAV4 owners and presents a safety concern. On 11/18/2025, the vehicle was inspected at Crabtree Toyota. The inspection confirmed rear liftgate hinge failure. The dealer provided video documentation and a written repair estimate. The health inspection also noted a separated and broken passenger-side rear hatch pulse sensor requiring replacement. Toyota closed my case without repairing the defect. Toyota offered a “good faith” credit of approximately 75% of the repair cost that cannot be applied to the liftgate structural or sensor repair and is only usable for unrelated future service. This appears to be a known, progressive defect involving rear liftgate hinges and related sensors on 2019 Toyota RAV4 vehicles. The condition presents a safety risk, as the liftgate may fail to stay open, close unexpectedly, or malfunction electronically. My VIN has been provided. Photos, video, and repair documentation are available upon requ

Lift cylinders of power liftgate are operating at different times causing gate to twist. Liftgate fails to open and close automatically, causing prolonged beeping while liftgate is open. Hinges holding liftgate in place have started to bend and crack apart from the body of the car. An independent auto body shop inspected this issue and recreated the tailgate failure. Quote to repair included replacing hinges, lift cylinders and to recheck electronic connections.

The contact owns a 2019 Toyota Rav4. The contact stated that while the vehicle was parked, the contact noticed fluid leaking from the driver’s side rear door. An unknown dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 40,000.

The contact owns a 2019 Toyota Rav4. The contact stated that the liftgate hinge had fractured into two pieces, causing the liftgate to fail to operate as designed. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the repair was not covered under recall or warranty. The failure mileage was approximately 60,000.

The contact owns a 2019 Toyota Rav4. The contact stated that while stopping the vehicle, the contact heard an abnormal slushing sound coming from the front passenger's side door. The vehicle was taken to the dealer, and it was determined that the door seals had failed and needed to be replaced. The vehicle was not yet repaired and remained with the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000. The VIN was unavailable.

Rear door liftgate hinges defective. They are too week combined with electric power struts. They are being pulled away from body of vehicle and become misshapen (bent, deformed,etc) and causes door/liftgate to be unbalanced and and stick out too far away from body. Now the door/liftgate can not close and be secured

Rear passenger door keeps flooding after rain. Bottom door seal needs to be physically lifted to the side for water to drain out of the door.

1st: veh purchased Jan 2023 with new set of tires. Within 11k miles, about 9months: Rear tires unable to be aligned properly due to no camber adjustment. Rear tires have excessive inner rear (belts showing) with 11k miles on tires. Took veh to dealership and was told I just need a set of tires and an alignment. When the tech was questioned if it was an accurate alignment, we were told it would be off a couple degrees because the OE rear control arms did not have any adjustment. This was repaired by an independent shop using aftermarket set of rear control arms, a proper alignment and 2 new rear tires ($1200)--because Toyota dealer would not own any accountability of an error nor do the PROPER requested repair since proper repair did not involve OE Toyota parts. This was repaired, case closed and tires have 20k miles on them with beautiful, even wear. 2nd: Rear door hatch will not close electronically. 2 incidences of bent (left) hinge from forcing the tailgate closed and damaged rear taillamp from mis-alignment. Post hinges replaced: re-sets have been done, disabling door and re-enabling, and disconnected battery. Still will not close electronically. This had been occurring over a year and no one knows the fix. I will not be going back to my local stealership and the next one is 30 miles away.

I bought my Rav4 in 2019 brand new. For years, anytime there is a hard rain, the doors fill up with water. Water does not drain properly. I brought my car into Toyota a couple of years back. They told me that there was no fix and that when that happens, just to lift up the weather stripping on all four doors, to let the water drain. They acted like this is completely normal. Just last week, I brought my car in again to Toyota to see if they had a fix for it. They ended up charging me about $700 to replace all of the weather stripping on the doors. This is very clearly a manufacturing default and the customer should not be charged for what is a common issue with this car! If this is a well known issue at this point, why has this not been recalled? Again, the doors have had issue draining the water properly since day one and the car was brand new! Anytime the doors fill with water, you can literally hear the water splashing around in the doors while driving! I am not a happy customer. Toyota never takes responsibility!

Back doors are completely water logged (full of water) and won't drain .

The rear hatch hinges cracked almost all the way through and had to be replaced. We were afraid to drive the vehicle because we didn’t want the hatch back to fall off while driving and create an accident.

When it rains, I have a puddle of water in the footboard of my backseats in the car.

Have had issues with the power gate to the hatchback since the first year of ownership. Dealer could not replicate after numerous complaints. On Jan 1, 2024 the hatch would only ho partially up or down and would not close. Upon looking, the hinges holding the hatch were pulling away from the vehicle. No accident, no abuse, nothing done other than using the electronic open/shut. Googled for info and found MANY similar/same complaints. Body shop estimate to replace hinges around $700 plus more for a rental. Toyota says it's not warranteed but I intend this is a definite structural problem with the vehicle. In the meantime the issue of the problems with electronic hatch lift cant be addressed due to hinge issue. Im concerned driving car --will hatch fall off in traffic??Recall should be issued imo.

For a long time, lift gate was not functioning correctly, when trying to close the liftgate does not close. In peak winters it was a lot of frustration to close the lift gate. Showed it dealership many times, later that issue worsened to hinge tear. Now it shows like falling apart. Requested to Toyota to repairs, repair is not done yet. Assistance in this regards would be highly appreciated.

The hinges on the rear power lift gate are tearing off of the vehicle. This is the second time they have failed. The first time I was told it was due to a manufacturing defect in the hinges, but now they (the Toyota dealership) are saying it is because the gate struts are not strong enough to support the door. Toyota is refusing to fix the issue calling it "wear and tear". The issue began when my car had around 45,000 miles. It now has 100,000 miles, but I started noticing the symptoms of the issue at 85,000 (the dealership "couldn't reproduce" at that time). The initial symptoms were the door giving a loud, long beep and refusing to open more than 3 inches or to close. Then, it started to thump as it closed. Sometimes it simply wouldn't open or close. Now, the door sits askew, with a large gap on one side as there is a significant tear in one hinge with a smaller tear on the other.. This is a safety issue because the hinges could break, causing the door to collapse on a person or fall off the car while in motion, with items in the rear of the vehicle also potentially flying out. The weak struts could also fail and collapse the door, causing injury. There are hundreds of similar complaints on Reddit and in RAV4 forums.

The back hatch was misaligned and over time became unusable. Upon inspection from the body shop the hinge the keeps the hatch attached to the vehicle at the top had pulled lose- the power hatch had essentially pulled away from the frame causing the misalignment. The manager at the body shop did some investigation and found that this was an issue that resulted in a recall for the same RAV 4 for the 2013-2017 models but had yet to be applied to our model year. After contacting the toyota dealership it was confirmed that this has been an issue that they are seeing- in fact, after paying for the repairs (since toyota refused to do so)- the body shop manager said she has had another customer with the same problem in the last 48 hours. This is absolutely not related to any accident of any kind- there wasn't one- this is clearly a manufacturer's problem.

Rainwater accumulates inside of doors. Drainage holes are easily blocked by dirt debris and unable to drain water from doors. Results in water sloshing around inside of door while driving.

Tailgate hinges ripping and tailgate will not close properly. no accident no abuse, this is something that is happening to a lot of Rav4's.

All 4 of the doors on my 2019 Toyota RAV4 have been filling full of water whenever it rains ever since I bought it from the dealership. Then the rainwater leaks out into the interior ceiling fabric, as well as the sides of the vehicle, staining it b/c black mold is growing! Also, it sounds like a cooler full of water sounds whenever the car is moving! Weighs it down too of course...also it frequently smells like something is burning inside the cabin, but can't figure out where it's coming from.

It was observed several points of rust and corrosion in the middle of the roof, and the paint and clear coat was out in this rust points.

Roof Rails are leaking and is a known issue. Water stains in the headliner and close to the side air bags. Smell of mildew causing health issues with my Asthma. Love the vehicle, but I do not trust that the air bags could or might not deploy or other electrical issues due to this.

The contact owns a 2019 Toyota Rav4. The contact stated while driving at various speeds, there was water leaking into the driver's side of the vehicle. The vehicle was taken to the local dealer; however, the failure could not be duplicated, and the vehicle was not repaired. The contact then stated that the failure persisted, and he noticed the water was leaking from the roof rack and had entered the air bag compartment area. The vehicle was taken back to the dealer, where it was diagnosed that the water was entering through the headliner; however, the vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 28,000.

The car leaks anytime it rains or I wash it. The water comes in above the front passenger and driver doors. The railing leaks into the front of the car.