1996 Toyota Tacoma Suspension

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING, THE REAR PASSENGER'S SIDE OF THE VEHICLE STARTED TO LOWER. AFTER STOPPING TO INSPECT THE VEHICLE, THE CONTACT DISCOVERED THE REAR CENTER LEAF SPRING HAD FRACTURED AND HAD ALSO PUNCTURED THE FUEL TANK CAUSING THE FUEL TO LEAK FROM THE VEHICLE. THE CONTACT INDICATED THAT THE FRACTURED LEAF SPRING WAS SEVERE RUSTED. AN UNKNOWN DEALER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED OR INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT THE PASSENGER SIDE SUSPENSION SUPPORT WAS DAMAGED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 96V129000 (SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE FOLSOM LAKE TOYOTA DEALER WAS CONTACTED AND REFUSED TO DO THE REPAIR BECAUSE THE FAILURE ALREADY OCCURRED ON THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 278,000. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME ON THE REAR PASSENGER'S SIDE TIRE BECAME DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 189,000.

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE FRONT PASSENGER'S SIDE SUSPENSION COLLAPSED. THE VEHICLE WAS TOWED TO A DEALER, WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 96V129000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT AFTER RECEIVING NOTIFICATION OF NHTSA CAMPAIGN I.D. NUMBER: 96V129000 (SUSPENSION:FRONT), THE VEHICLE WAS TAKEN TO THE DEALER HOWEVER, THE DEALER REFUSED REPAIRS DUE TO THE VEHICLE AGE. THE CONTACT DID NOT CALL THE MANUFACTURER. THE FAILURE MILEAGE WAS 154,000.

TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 96V129000 (SUSPENSION:FRONT). THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS AND THE DEALER CONFIRMED THAT THE FRAME WAS CORRODED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE RECALL WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 114,869 AND THE CURRENT MILEAGE WAS 114,879.

DURING PA STATE INSPECTION, NOTIFIED BY DEALER THAT BOTH REAR LEAF SPRINGS WERE BROKEN. DEALER WANTED $1200 + TO REPLACE. I FOUND A LOCAL SHOP TO REPLACE THEM WITH AFTERMARKET PARTS FOR UNDER $800. TOYOTA KNOWS THERE IS A PROBLEM WITH THESE SPRINGS AND YET STILL TRIES TO MILK THE OWNERS FOR MORE $. *TR

BROKEN REAR DRIVER SIDE LEAF SPRINGS ON 1996 TOYOTA TACOMA 4WD EXTENDED CAB LED TO POOR VEHICULAR CONTROL AND TIRE DAMAGE*AK

THERE REAR OF THE VEHICLE MADE NOISE. *JB THE VEHICLE WAS RETURNED TO THE DEALER BECAUSE THE NOISE COULD NOT BE RESOLVED. THE CONSUMER BELIEVES THE DEALER RESOLD THE VEHICLE WITHOUT IT BEING REPAIRED. *NM

RIGHT SIDE REAR LEAF SPRING BROKE IN HALF AT 79,000 MILES. RODLAND TOYOTA IN EVERETT, WA. STATED THIS IS NOT COVERED UNDER THE EXTENDED WARRANTY. THE SERVICE DEPARTMENT DID NOT MENTION THIS AS A KNOWN PROBLEM. NO OFFERS WERE EXTENDED TO CORRECT THE DEFECT. NO MENTION WAS MADE WHEN I PURCHASED THE TRUCK 6 MONTHS AGO (OCT. 03). TRUCK WAS SAID TO BE IN EXCELLENT CONDITION.

BAD REAR LEAF SPRINGS, CAUSING EXTREME INSTABILITY. VEHICLE: 1996 TOYOTA TACOMA 4X4 REGULAR CAB, REGULAR BED, 4CYLINDER. THE MIDDLE REAR LEAF SPRING HAS A TENDANCY TO BREAK, EVEN UNDER LIGHT LOADS.*AK ON MY TRUCK, THE DRIVER'S SIDE BROKE AT AROUND 100,000 MILES, THE PASSENGER SIDE BROKE AT ABOUT 110,000 MILES. THIS CREATED TWO PROBLEMS: 1) THE REAR OF THE TRUCK TENDS TO LEAVE THE GROUND ON EVEN SMALL BUMPS. 2) THERE IS LESS WEIGHT TOWARDS THE FRONT OF THE VEHICLE, CAUSING A SERIOUS DEGRADATION IN STEERING CONTROL. MY SPRINGS BROKE WITH NO LOAD, I HEARD IT HAPPEN EACH TIME. I CONTACTED A TOYOTA DEALERSHIP EXPECTING THERE IS SOME SORT OF RECALL ON THESE SPRINGS, THEY SAID NO, BUT THERE WAS A 'TECHNICAL BULLETIN' FOR REPLACEMENT OF THESE SPRINGS. TOYOTA WOULD NOT PAY FOR THE REPLACEMENT, EXCEPT IF UNDER WARRANTY. (MY WARRANTY EXPIRED AT 100,000 MILES) THEY WANTED $345 EACH SIDE, PLUS LABOR TO HAVE THE PROBLEM FIXED. THERE WAS NO WAY I COULD AFFORD IT. I DROVE AROUND WITH FOR A YEAR AND A HALF WITH A BROKEN LEAF SPRING ON EACH SIDE, WONDERING WHEN I WOULD GET IN A CRASH. HOW MANY OTHER TACOMA'S OUT THERE HAVE THIS SAME PROBLEM? MANY! I DID SOME RESEARCH INTO FIXING THE PROBLEM MYSELF. I CALLED A LOCAL TOYOTA REPAIR SHOP (NOT THE DEALERSHIP), THEY STATED THAT THIS IS A MAJOR AND VERY VERY COMMON PROBLEM WITH 1996 TACOMA'S, THAT I WAS THE FOURTH CALLER FOR THAT DAY ALONE ASKING ABOUT THE SPRINGS. DOING MORE RESEARCH ON THE INTERNET, I LEARNED ABOUT COUNTLESS CASES OF BOTH LEAF SPRINGS BREAKING, WITH AND WITHOUT A LOAD. THIS NEEDS TO BE A SAFETY RECALL BECAUSE THE SPRINGS ARE PRONE TO FAILURE AND THE VEHICLE IS EXTREMELY UNSTABLE WHEN THEY ARE BROKEN. I HAVE HIGH QUALITY DIGITAL PHOTO'S AVAILABLE, THE WEB SITE IS STILL BEING DEVELOPED HTTP://TACOMASPRINGS.HOME.COMCAST.NET EMAIL OR CALL, I CAN SEND OUT THE WHOLE CD, I HAVE MORE THAN 50 PHOTOS TOTAL, ALL TAKEN AT 3.1MEGPIXEL. [email protected] THANK YOU. SEAN

FAULTY SPEEDOMETER. FRONT END SUSPENSION FAULTY,LEAF SPRING NOISE. *AK

TOP OF THE SHOCK ABSORBER MOUNT DETACHED FROM THE FRAME BECAUSE OF METAL FAILURE. *NLM

REAR LEAF SPRING ON PASSENGER SIDE (# 2 LEAF) HAS CRACKED, LEADING TO UNPREDICTABLE REAR SUSPESION BEHAVIOR OVER BUMPS. THIS IS A WIDELY KNOWN PROBLEM. TOYOTA IS AWARE THAT THERE IS A HIGH FAILURE RATE ON TACOMA LEAF SPRINGS, AS ARE ALL PARTS AND SERVICE PERSONNEL THAT I HAVE SPOKEN TO. THIS IS A VERY EXPENSIVE REPAIR FOR A KNOWN PROBLEM, TOYOTA SHOULD BE PROVIDING ASSISTANCE/RECALL.

WHILE DRIVING, UPPER AND LOWER BALL JOINTS BROKE AND FRONT END FELL, CAUSING MAJOR DAMAGE TO OTHER COMPONENTS IN VEHICLE.*AK

IT APPEARS TO ME THAT TOYOTA HAS USED A BAD QUALITY SPRING STEEL NOT ONLY HAVE MY CRACKED BUT SO HAVE EVREYONE THAT I HAVE TALK TO. THE SALVAGE YARD HAS TOLD ME THAT AS SOON AS THEY GET SOME IN THAT ARE NOT CRACKED THEY ARE SOLD FAST, I WAS TOLD BY TWO DIFRENT SPRING SERVICE COMPANYS IN TOWN THAT ALL THE TACOMA SPRINGS CRACK WHAT IS THIS AM I THE FIRST PERSON TO REPORT THIS THE DANGER HERE IS IF THE CENTER LEAF FALLS OUT LIKE MINE DID IT COULD STAB THE TIRES AND CAUSE ONE HECK OF A ACCIDENT, I ALWAYS LOVED MY TOYOTA BUT COME ON A CRACKED LEAF SPRING AND THEY WANT 375.00 EACH FOR THEM AT A SPRING SHOP LORD KNOWS WHAT TOYOTAS GETTING. THANK YOU MARK GIANOPOULOS. *AK

CONSUMER STATES THAT WHILE DRIVING AND WITHOUT WARNING THE BALL JOINT SNAP CAUSING THE FRONT DRIVER SIDE WHEEL TO SEPARATE AND THE CONSUMER WILL HAVE TO PULL OVER. DEALER NOTIFIED. TS

REAR SUSPENSION SUPPORT SPRING HAS CRYSTALLIZED. *AK

FRONT SUSPENSION SUPPORT BRACKET BAR SNAPPED FROM FRAME.*AK

BRACKET THAT HOLDS COIL SPRING ONTO FRAME ON DRIVER'S SIDE BROKE. MANUFACTURER NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION CONCERNING THIS MATTER.*AK

NOTICED RIGHT REAR WHEEL BOUNCE, INVESTIGATED NOTICED MIDDLE LEAF PROTRUDING AND RUBBING ON SHOCK ABSORBER. CALLED TOYOTA ABOUT PROBLEM, THEY INDICATED THAT THEY WOULD NOT REPLACE IT, AND I HAD TO TAKE IT BACK TO THE DEALER FOR REPAIR AT MY EXPENSE. CALLED DEALER, DEALER SAID BOTH LEAF SPRINGS SHOULD BE REPLACED ON LEFT AND RIGHT SIDES. REPAIR COST WOULD BE AROUND $1200.00. ONE OTHER NOTE, THIS TRUCK WAS NEVER USED TO CARRY LARGE LOADS. *AK

WHILE TURNING LEFT INTO A PARKING SPACE LEFT FRONT OF VEHICLE FELL TO GROUND. DEALER VERIFIED THAT FRONT LEFT BALL JOINT BROKE. SIMILAR TO RECALL 96V129000. *AK

RIGHT REAR SPRING IS BROKEN, I HAD IT FIXED ONCE BEFORE AT AN INDIPENDENT REPAIR SHOP. THIS IS A KNOWN PROBLEM WITH TOYOTAS REAR SPRINGS I WOULD LIKE TO KNOW WHAT THE NHTSA IS DOING ABOUT IT SINCE IT IS A SAFETY PROBLEM. *AK

BOTH REAR LEAF SPRINGS CRACKED, THIS IS A PROBLEM TOYOTA IS AWARE OF BUT WON'T REPAIR AT THEIR EXPENSE, TOYOTA CLAIMS IT IS NOT DANGEROUS, PERHAPS AFTER FIRST DEATH THEY WILL TAKE NOTICE

REAR LEAF SPRING BROKE. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK